NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
43 reportsClear category filterMileage unknown · Feb 14, 2026
EngineForward Collision AvoidancePower Train
THERE ARE SWVERAL ISSUES WITH THIS MODEL, THE WORST BEING THE CONSTANT JERKING/ BUCKING WHILE DRIVING. THE SECOND BEING THE FORWARD COLLISION WARNING ALERTING WHEN NO VEHICLES ARE NEAR YOU, IT JUST RANDOMLY ALERTS.THE THIRD MOST ANNOYING ISSUE IS THE DASHBOARD FROM TIME TO TIME GOES OUT AS IF NO ELECTRICTY IS FLOWING THROUGHT IT…
Read full complaint
THERE ARE SWVERAL ISSUES WITH THIS MODEL, THE WORST BEING THE CONSTANT JERKING/ BUCKING WHILE DRIVING. THE SECOND BEING THE FORWARD COLLISION WARNING ALERTING WHEN NO VEHICLES ARE NEAR YOU, IT JUST RANDOMLY ALERTS.THE THIRD MOST ANNOYING ISSUE IS THE DASHBOARD FROM TIME TO TIME GOES OUT AS IF NO ELECTRICTY IS FLOWING THROUGHT IT, IVE ALSO EXPERINCED THE VOLUME NOT ADJUSTING PROPERLY AT TIMES.
NHTSA ODI #11717958
Mileage unknown · Feb 2, 2026
EngineFuel/propulsion SystemPower Train
IT HAS A RECALL 25S76 THAT FORD SAYS HAS NO SOLUTION. I CALLED FORD, AND THEY SAID IT DID HAVE ONE, AND THAT I SHOULD TAKE IT IN. SUPPOSEDLY, WHAT THEY DID WAS A SOFTWARE UPDATE ON 05/01/2025, BUT NOTHING WORKED. The gasoline smell inside the car persists, with a risk of fire.
NHTSA ODI #11714953
81,881 miles · Dec 29, 2025
Fuel System, GasolinePower Train
The contact owns a 2021 Ford Escape. The contact stated that the vehicle failed to respond while in reverse(R). In addition, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The …
Read full complaint
The contact owns a 2021 Ford Escape. The contact stated that the vehicle failed to respond while in reverse(R). In addition, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The vehicle was then taken to an independent mechanic, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. In addition, the contact received recall notification NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however ,the parts to do the recall repair were not available. The contact stated that the recall fire risk was significantly scary and made the vehicle unsafe to drive. The manufacturer was not made aware of the failure. The failure mileage was approximately 81,881.
NHTSA ODI #11707609
Mileage unknown · Nov 4, 2025
EnginePower Train
2021 Ford Escape. In January 2025 the turbo system failed and was replaced by a Ford dealer for about $5,903.85. Around five months later the transmission required repairs for a valve body issue, totaling roughly $3,000 in August. Two months after that repair, Firestone advised that the entire transmission now needs replacement.…
Read full complaint
2021 Ford Escape. In January 2025 the turbo system failed and was replaced by a Ford dealer for about $5,903.85. Around five months later the transmission required repairs for a valve body issue, totaling roughly $3,000 in August. Two months after that repair, Firestone advised that the entire transmission now needs replacement. Each time the problem appeared, the vehicle showed violent slippage while upshifting and downshifting. When coming to a stop, the car would shake violently, slip forward several inches while my foot was still on the brake, and sometimes hesitate or lose power. Recently the vehicle will stop responding to acceleration, then suddenly surge forward without warning. These repeated transmission failures have created serious safety risks and appear consistent with ongoing problems involving the Ford 8F35 transmission used in the 2021 Escape.
NHTSA ODI #11697350
Mileage unknown · Oct 18, 2025
EnginePower TrainUnknown Or Other
Lots of owners on Facebook page 2020/2021 ford escape discussions talk about our transmissions fluttering when driving straight you can see rpm’s going from one to under one back in a straight road some have had the transitions go out. I took mine to ford at 111000 miles and was told I need to pay $500 to change fluid did that a…
Read full complaint
Lots of owners on Facebook page 2020/2021 ford escape discussions talk about our transmissions fluttering when driving straight you can see rpm’s going from one to under one back in a straight road some have had the transitions go out. I took mine to ford at 111000 miles and was told I need to pay $500 to change fluid did that and still doing it they said everything was fine but I should look into a extended warranty because they have had a lot of issues with the transition (was told that by auto nation ford in Corpus Christi tx? We all even have issues with Rear differential going out
NHTSA ODI #11694264
40,000 miles · Sep 17, 2025
Fuel System, GasolinePower Train
The contact owns a 2021 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that after an oil change at Firestone, the vehicle failed to operate as intended. The contact stated that the vehi…
Read full complaint
The contact owns a 2021 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that after an oil change at Firestone, the vehicle failed to operate as intended. The contact stated that the vehicle vibrated abnormally. The vehicle was taken to the dealer however, no cause for the failure was found. The failure persisted. While driving at 15 MPH, the vehicle vibrated abnormally. The vehicle was taken back to the dealer, who refused to repair the vehicle, stating that the vehicle had already been repaired. The contact's son noticed that a cover was missing under the steering wheel, and an unknown part was fractured. The dealer denied any wrongdoing. The contact spoke with an employee who spoke Spanish and translated to the contact that an unknown part was damaged in the transmission. The dealer denied causing the issue. The contact stated that the dealer refused to repair the vehicle. The failure recurred, and the contact parked the vehicle. The vehicle was no longer driven due to safety concerns. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 40,000.
NHTSA ODI #11687894
Mileage unknown · Sep 10, 2025
Power Train
On 8/18/2025, the transmission on my vehicle failed. I was only going about 35 mph when the entire vehicle went into chaos. Prior to this, no lights were on that indicated that I had a major problem. My car shut down in the middle of a busy road and I was able to get it to roll to a nearby parking lot. I have seen hundreds of pe…
Read full complaint
On 8/18/2025, the transmission on my vehicle failed. I was only going about 35 mph when the entire vehicle went into chaos. Prior to this, no lights were on that indicated that I had a major problem. My car shut down in the middle of a busy road and I was able to get it to roll to a nearby parking lot. I have seen hundreds of people complain online and on forums about 2020-2021 Ford Eacapes having transmission issues. I had my vehicle towed to the dealership and they were able to confirm that it was the transmission. The powertrain warranty is covering the repair, but I have to pay about $1000 out of pocket. Ford needs to be made aware of their faulty transmissions. I have never, in my life, purchased a vehicle brand new (0 miles) and had to make such a repair before my vehicle even has 100K miles on it. I am highly disappointed and I regret buying it. Luckily, I was the only one in the car when it shut down because it could have been really bad. Cars were swerving around me and I was extremely afraid.
NHTSA ODI #11686480
73,925 miles · Apr 11, 2025
Power Train
The contact owns a 2021 Ford Escape. The contact stated while driving at 50 MPH and depressing the accelerator pedal, the vehicle hesitated to respond as needed. No warning light was illuminated. The contact was able to drive to the residence. The vehicle was towed to the dealer, where it was diagnosed and determined that the tr…
Read full complaint
The contact owns a 2021 Ford Escape. The contact stated while driving at 50 MPH and depressing the accelerator pedal, the vehicle hesitated to respond as needed. No warning light was illuminated. The contact was able to drive to the residence. The vehicle was towed to the dealer, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The manufacturer transferred the contact to the NHTSA Hotline to file a safety complaint. The approximate failure mileage was 73,925.
NHTSA ODI #11654063
Mileage unknown · Mar 13, 2025
Electrical SystemPower Train
I was driving my 2021 Ford Escape, that I have not yet owned for four years, that I purchased brand new from a Ford dealership. I was driving to work just as I do on a typical morning at interstate speeds, when suddenly, the car refused to upshift, slipping gears. The car became jerky. I tried to accelerate back up to speed. The…
Read full complaint
I was driving my 2021 Ford Escape, that I have not yet owned for four years, that I purchased brand new from a Ford dealership. I was driving to work just as I do on a typical morning at interstate speeds, when suddenly, the car refused to upshift, slipping gears. The car became jerky. I tried to accelerate back up to speed. The car was not moving and the RPM reading shot into the red. I see a large vehicle approaching me, and I begin to feel terror that I could become the victim of a car crash, due to a faulty Ford transmission! This moment was psychologically damaging, as I feared for my life. Eventually, the car regained speed slowly and I continued on my way. Then, at stoplights, the car continued to jerk and shift gears. Once I reached my destination, the car slammed into park, throwing me toward the steering wheel. My husband towed my car home. It has been taken to a local dealership where I received a quote for a new transmission and an oil leak repair, totaling over $11,000. This car at trade-in value is worth a similar amount. The transmission fluid was tested and found to be burnt and containing traces of metal in the fluid. The dealership has been helpful in diagnosing the repair. But from Ford, this low-standard is unacceptable. I could have been killed, injured, and caused harm to others due to this faulty transmission. I have reason to believe based on a class action lawsuit that took place in March of 2024, Ford knowingly placed faulty parts and transmissions into Ford Escape models that were produced from 2009-2021. I have called Ford corporate. They offered little to no empathy, offering a small amount of assistance, which was highly disappointing.
NHTSA ODI #11648095
Mileage unknown · Jan 26, 2025
Power TrainVehicle Speed Control
Over the past 4 months the powertrain malfunction light has illuminated 4 times on random occasions. The first time it came on while I was driving home from shopping. I did not notice the light until I stalled in the intersection trying to get on to the interstate. Stopped at the Ford dealership and insisted they scan it while t…
Read full complaint
Over the past 4 months the powertrain malfunction light has illuminated 4 times on random occasions. The first time it came on while I was driving home from shopping. I did not notice the light until I stalled in the intersection trying to get on to the interstate. Stopped at the Ford dealership and insisted they scan it while the light was on. They refused and kept it for 2 days to tell me there was nothing wrong. Two weeks later, I was again traveling at an average speed. The light illuminated. Stopped at Advanced Auto Parts as it was late evening and Ford was closed. They could not pull a code with the light on stating it could be electrical. Towed the car home on a trailer from 45 minutes away. Upon inspection we discovered the coolant was low, added coolant and light went away. No issues for 3 months after that. The third time it came on I was accelerating on to the interstate. The engine was still pretty cold. The car went into limp mode and struggled to accelerate to highway speed. I parked the car and the light went away after sitting for a few hours. I thought it could be the oil was low or dirty. Took vehicle for oil change at Ford and they could see the light triggering but no code. Light did not come back for about 3 weeks. Fourth time I was driving at an average speed. Light came on and I was able to take vehicle directly to Ford again. Ford scanned the car while running with the light on and got a code for throttle/pedal sensor issues. The throttle position sensor was changed in July 2023. The car is currently at Ford awaiting a diagnosis and replacement of the issue. The powertrain light illuminating is a repeated issue with this vehicle.
NHTSA ODI #11638578
Official recalls
19Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.
Consequence & remedy
Consequence: Windshield wipers that fail to operate properly can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the front wiper motors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed April 2, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S14. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the accessory protocol interface module (APIM) software, free of charge. Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Dec 1, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2025 Escape vehicles. The liftgate hinge covers may not be properly secured and detach from the vehicle.
Consequence & remedy
Consequence: A detached liftgate hinge cover can create a distraction or a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and reinstall, or replace any missing liftgate hinge covers as necessary, free of charge. Owner notification letters were mailed June 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SD6. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 3, 2025.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Jul 11, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the engine control software. In addition, dealers will replace the high-pressure fuel rail assembly and fuel injectors, free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.
Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Consequence & remedy
Consequence: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Remedy: Owners are advised not to charge battery till the remedy has been completed. Dealers will perform a battery energy control module (BECM) software update, and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on May 30, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S79.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
May 10, 2024
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will update the HPCM software, free of charge. Owner notification letters were mailed May 22, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S33.
May 26, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.
Nov 18, 2022
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.
Jul 7, 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.
Additional source detail variants (3)
Structure:body:bumpers:active Shutters/grill
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.
Engine And Engine Cooling
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.
Mar 25, 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.
Consequence & remedy
Consequence: An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.
Mar 11, 2022
Ford Motor Company (Ford) is recalling certain 2022 Corsair and 2021-2022 Escape vehicles equipped with a 2.5L Hybrid powertrain. The high voltage battery may fail, resulting in a sudden loss of drive power.
Consequence & remedy
Consequence: A sudden loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the high voltage battery, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S48.
Additional source detail variants (2)
Electrical System:propulsion System:traction Battery
Ford Motor Company (Ford) is recalling certain 2022 Corsair and 2021-2022 Escape vehicles equipped with a 2.5L Hybrid powertrain. The high voltage battery may fail, resulting in a sudden loss of drive power.
Consequence: A sudden loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the high voltage battery, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S48.
Hybrid Propulsion System
Ford Motor Company (Ford) is recalling certain 2022 Corsair and 2021-2022 Escape vehicles equipped with a 2.5L Hybrid powertrain. The high voltage battery may fail, resulting in a sudden loss of drive power.
Consequence: A sudden loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the high voltage battery, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S48.
Nov 23, 2021
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco Sport and Escape vehicles. The rear brake linings may have been manufactured incorrectly, which can affect braking performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: During certain situations, the driver may have to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash.
Remedy: Dealers will replace the front brake pads, free of charge. Owner notification letters were mailed August 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C31.
Nov 10, 2021
Ford Motor Company (Ford) is recalling one 2021 Escape vehicle equipped with a 2.5L hybrid powertrain. The high voltage battery may fail, resulting in a sudden loss of drive power.
Consequence & remedy
Consequence: A sudden loss of drive power increases the risk of a crash.
Remedy: A dealer will replace the high voltage battery, free of charge. The owner notification letters were mailed December 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S48.
Additional source detail variants (2)
Hybrid Propulsion System
Ford Motor Company (Ford) is recalling one 2021 Escape vehicle equipped with a 2.5L hybrid powertrain. The high voltage battery may fail, resulting in a sudden loss of drive power.
Consequence: A sudden loss of drive power increases the risk of a crash.
Remedy: A dealer will replace the high voltage battery, free of charge. The owner notification letters were mailed December 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S48.
Electrical System:propulsion System:traction Battery
Ford Motor Company (Ford) is recalling one 2021 Escape vehicle equipped with a 2.5L hybrid powertrain. The high voltage battery may fail, resulting in a sudden loss of drive power.
Consequence: A sudden loss of drive power increases the risk of a crash.
Remedy: A dealer will replace the high voltage battery, free of charge. The owner notification letters were mailed December 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S48.
Aug 10, 2021
Ford Motor Company (Ford) is recalling certain 2021 Escape, Lincoln Corsair, and 2021-2022 Bronco Sport vehicles. The fuel delivery module may leak inside the fuel tank, causing low fuel pressure which could result in an engine stall.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the fuel delivery module, free of charge. Interim notification letters (remedy not available) were mailed on September 30, 2021. Owner notification letters were mailed on December 14, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S38.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23013 · Failed Door Check Arm Attachment Point
Opened Jul 7, 2023 · Closed Jan 24, 2024
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:door:hinge And Attachments
On July 7, 2023, the Office of Defects Investigation (ODI) opened PE23-013 to investigate instances of check arm bracket failure in the front doors in model year (MY) 2020-2021 Ford Escape vehicles. At the time of opening, ODI received 118 Vehicle Owner Questionnaires (VOQs) alleging this failure. To date, ODI has received 593 VOQs alleging this failure, with a variety of reported failure conditions. The most common reported failure condition was reduced door functionality (e.g. door was more difficult to open or close) and the least common was inadvertent door opening. Other reported failure conditions include inability to latch and inability to open. Three VOQs reported injuries, one of which requiring medical attention. ODI conducted a consumer survey which yielded an additional 44 injuries (although the VOQs did not indicate any injury), none of which requiring medical attention. All these injuries were bumps/bruises from the door closing on occupants’ arms and legs while entering and exiting the vehicle. The function of the check arm system is to provide hold-open assist at specific angles and to assist with door closing energy. It does not provide vertical support of the door and is independent of the latching mechanism. This failure is progressive and detectable by vehicle occupants. Consumers commonly report hearing a popping or snapping noise when opening and closing the door. This noise is caused by some of the welds between the bracket and door structure failing and detaching. There may also be visible damage present to the welds in the door structure. Continued use of the door may result in all welds separating and the bracket fully detaching from the door structure, which could lead to increased resistance in closing and opening the door, restrained window operation, and the door freely rotating when open. ODI inspected 3 consumer vehicles in the field, and 2 test vehicles at Ford’s testing facility. The test vehicles were retrofitted with the failed component. ODI observed an increased door closing resistance, however, was unable to reproduce an inadvertent open while parked or driving, or a failure to latch or open condition. Testing also verified this failure did not affect the door ajar warning system. This system provides an audible and visual warning in the event a door did not achieve primary latch position. Ford has provided details on a one-time-repair customer satisfaction program (23B56), stating that they will provide customers with a letter, currently targeted for March 2024, to bring their vehicle to a Ford dealership for a proactive repair. Dealers will inspect the door check arm welds for damage and will either provide a rivet plate to reinforce the existing door check arm or will provide a replacement door, depending on the level of damage present. Customers will be eligible for reimbursement if they previously paid to repair this issue. In view of the high detectability of failure, low potential hazard to drivers, and Ford’s customer satisfaction program to provide a proactive repair, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Structure:body:door
On July 7, 2023, the Office of Defects Investigation (ODI) opened PE23-013 to investigate instances of check arm bracket failure in the front doors in model year (MY) 2020-2021 Ford Escape vehicles. At the time of opening, ODI received 118 Vehicle Owner Questionnaires (VOQs) alleging this failure. To date, ODI has received 593 VOQs alleging this failure, with a variety of reported failure conditions. The most common reported failure condition was reduced door functionality (e.g. door was more difficult to open or close) and the least common was inadvertent door opening. Other reported failure conditions include inability to latch and inability to open. Three VOQs reported injuries, one of which requiring medical attention. ODI conducted a consumer survey which yielded an additional 44 injuries (although the VOQs did not indicate any injury), none of which requiring medical attention. All these injuries were bumps/bruises from the door closing on occupants’ arms and legs while entering and exiting the vehicle. The function of the check arm system is to provide hold-open assist at specific angles and to assist with door closing energy. It does not provide vertical support of the door and is independent of the latching mechanism. This failure is progressive and detectable by vehicle occupants. Consumers commonly report hearing a popping or snapping noise when opening and closing the door. This noise is caused by some of the welds between the bracket and door structure failing and detaching. There may also be visible damage present to the welds in the door structure. Continued use of the door may result in all welds separating and the bracket fully detaching from the door structure, which could lead to increased resistance in closing and opening the door, restrained window operation, and the door freely rotating when open. ODI inspected 3 consumer vehicles in the field, and 2 test vehicles at Ford’s testing facility. The test vehicles were retrofitted with the failed component. ODI observed an increased door closing resistance, however, was unable to reproduce an inadvertent open while parked or driving, or a failure to latch or open condition. Testing also verified this failure did not affect the door ajar warning system. This system provides an audible and visual warning in the event a door did not achieve primary latch position. Ford has provided details on a one-time-repair customer satisfaction program (23B56), stating that they will provide customers with a letter, currently targeted for March 2024, to bring their vehicle to a Ford dealership for a proactive repair. Dealers will inspect the door check arm welds for damage and will either provide a rivet plate to reinforce the existing door check arm or will provide a replacement door, depending on the level of damage present. Customers will be eligible for reimbursement if they previously paid to repair this issue. In view of the high detectability of failure, low potential hazard to drivers, and Ford’s customer satisfaction program to provide a proactive repair, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:door:hinge And Attachments
On July 7, 2023, the Office of Defects Investigation (ODI) opened PE23-013 to investigate instances of check arm bracket failure in the front doors in model year (MY) 2020-2021 Ford Escape vehicles. At the time of opening, ODI received 118 Vehicle Owner Questionnaires (VOQs) alleging this failure. To date, ODI has received 593 VOQs alleging this failure, with a variety of reported failure conditions. The most common reported failure condition was reduced door functionality (e.g. door was more difficult to open or close) and the least common was inadvertent door opening. Other reported failure conditions include inability to latch and inability to open. Three VOQs reported injuries, one of which requiring medical attention. ODI conducted a consumer survey which yielded an additional 44 injuries (although the VOQs did not indicate any injury), none of which requiring medical attention. All these injuries were bumps/bruises from the door closing on occupants’ arms and legs while entering and exiting the vehicle. The function of the check arm system is to provide hold-open assist at specific angles and to assist with door closing energy. It does not provide vertical support of the door and is independent of the latching mechanism. This failure is progressive and detectable by vehicle occupants. Consumers commonly report hearing a popping or snapping noise when opening and closing the door. This noise is caused by some of the welds between the bracket and door structure failing and detaching. There may also be visible damage present to the welds in the door structure. Continued use of the door may result in all welds separating and the bracket fully detaching from the door structure, which could lead to increased resistance in closing and opening the door, restrained window operation, and the door freely rotating when open. ODI inspected 3 consumer vehicles in the field, and 2 test vehicles at Ford’s testing facility. The test vehicles were retrofitted with the failed component. ODI observed an increased door closing resistance, however, was unable to reproduce an inadvertent open while parked or driving, or a failure to latch or open condition. Testing also verified this failure did not affect the door ajar warning system. This system provides an audible and visual warning in the event a door did not achieve primary latch position. Ford has provided details on a one-time-repair customer satisfaction program (23B56), stating that they will provide customers with a letter, currently targeted for March 2024, to bring their vehicle to a Ford dealership for a proactive repair. Dealers will inspect the door check arm welds for damage and will either provide a rivet plate to reinforce the existing door check arm or will provide a replacement door, depending on the level of damage present. Customers will be eligible for reimbursement if they previously paid to repair this issue. In view of the high detectability of failure, low potential hazard to drivers, and Ford’s customer satisfaction program to provide a proactive repair, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ22002 · Healey Brothers Ford / Open Recall Sale
Opened Jun 3, 2022 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump:control/drive Module
NHTSA is opening this audit query to investigate whether Healey Brothers Ford, LLC of Beacon, New York, has complied with the requirements of the National Traffic and Motor Vehicle Safety Act. The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and noncompliance with Federal Motor Vehicle Safety Standards and in turn that a dealer not deliver a new vehicle subject to a recall unless the recall remedy has been performed. 49 U.S.C. § 30120(i).NHTSA is in receipt of information that indicates this dealer delivered at least one new vehicle to a first purchaser without having performed required recall repairs. Accordingly, we are opening this audit query to seek additional information concerning this issue.
Illustration