NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
108 reports61,000 miles · Jun 23, 2026
Electrical SystemFire
The contact owned a 2023 Ford Explorer. When the contact’s husband activated the air conditioning system after the vehicle had been parked for several hours, a fire started underneath the console inside the vehicle. The driver pulled over to the side of the road, where onlookers assisted with extinguishing the fire with a fire e…
Read full complaint
The contact owned a 2023 Ford Explorer. When the contact’s husband activated the air conditioning system after the vehicle had been parked for several hours, a fire started underneath the console inside the vehicle. The driver pulled over to the side of the road, where onlookers assisted with extinguishing the fire with a fire extinguisher. The contact’s husband received burns on his fingers. Medical attention was not needed. The Fire Department was not contacted. The vehicle was towed to the dealer to be inspected; however, the cause of the failure was not determined. The vehicle was deemed a total loss. The contact was provided with photos of the vehicle and became aware that the wiring was burned. The manufacturer was not made aware of the issue. The failure mileage was approximately 61,000.
NHTSA ODI #11745964
Mileage unknown · Jun 14, 2026
Suspension
Premature leaking and failure on rear shocks absorbers. Premature failure could lead to handling issues and interference with driver assist handling, action control etc. Some say this is a know issue but not one that has prompted a recall
NHTSA ODI #11744038
Mileage unknown · Jun 11, 2026
Suspension
The rear subframe bushing is torn, resulting in the rear of the vehicle to sway side to side when traveling down the road at highway speeds, making it difficult to maintain lanes. Bushings are not covered by the 60k power train warranty, and resulting in a 2-3,000 dollar repair due to subframe in rear of vehicle needing dropped …
Read full complaint
The rear subframe bushing is torn, resulting in the rear of the vehicle to sway side to side when traveling down the road at highway speeds, making it difficult to maintain lanes. Bushings are not covered by the 60k power train warranty, and resulting in a 2-3,000 dollar repair due to subframe in rear of vehicle needing dropped and bushing pressed out or entire subframe to be replaced.
NHTSA ODI #11743490
Mileage unknown · Jun 11, 2026
Unknown Or OtherInjury
The chrome/ brushed finish peeling along the top of the center console, resulting in sharp edges. The vehicle is just outside of bumper to bumper warranty and the fix is out of pocket. Vehicle current has 55k miles on it, and bubbling down both sides of the laminated trim.
NHTSA ODI #11743487
Mileage unknown · Jun 1, 2026
Forward Collision Avoidance
Precollision assist warnings on in the car saying system unavailable. Took to the dealer and showed me the sensor for this was broken and my cost would be $1800 to repair. My vehicle only has 16000 miles on it and is covered by an extended warranty and 3 year BTB warranty. Dealer claims the sensor was hit by an external force so…
Read full complaint
Precollision assist warnings on in the car saying system unavailable. Took to the dealer and showed me the sensor for this was broken and my cost would be $1800 to repair. My vehicle only has 16000 miles on it and is covered by an extended warranty and 3 year BTB warranty. Dealer claims the sensor was hit by an external force so it wasn't covered. I said we have hit nothing and my vehicle shows no damage. Internet says these can fail by bumper collision or hitting a pot hole. I think it is a vehicle safety issue that you don't design something that can withstand hitting a bump or pot hole or why wouldn't you give clearance for the bumper to flex. Ford can't tell me what happened to the sensor and to me that is a safety issue. I spoke with the service advisor and went up to service manager and called Ford customer care and they refuse to do anything about it.
NHTSA ODI #11741254
Mileage unknown · May 26, 2026
Unknown Or Other
Vehicle: 2023 Ford Explorer Recall Number 25S49 (NHTSA:25V315) I am filing this complaint regarding a failed recall remedy & my Ford dealership's refusal to re-repair my vehicle. The recall remedy was previously performed at an authorized Ford dealership. The defect has since recurred, my infotainment screen is completely bla…
Read full complaint
Vehicle: 2023 Ford Explorer Recall Number 25S49 (NHTSA:25V315) I am filing this complaint regarding a failed recall remedy & my Ford dealership's refusal to re-repair my vehicle. The recall remedy was previously performed at an authorized Ford dealership. The defect has since recurred, my infotainment screen is completely black & non-functional at all times, leaving me with no rear-view camera visibility when reversing, which is an ongoing safety hazard. When I returned to the dealership they refused to perform a second repair under the recall. Dealer records confirm the original repair was completed. I am requesting the NHTSA document this complaint, investigate the failed remedy & require Ford to provide a durable fix for vehicles where the recall repair did not hold.
NHTSA ODI #11740112
43,000 miles · May 21, 2026
Air BagsCrashInjury
The contact owns a 2023 Ford Explorer. The contact stated that while her boyfriend was driving at 40 MPH, another vehicle did not stop at a stop sign and crashed into the front passenger side of the vehicle. All of the air bags deployed. The contact's boyfriend suffered bruising to the wrist and left upper arm and redness on the…
Read full complaint
The contact owns a 2023 Ford Explorer. The contact stated that while her boyfriend was driving at 40 MPH, another vehicle did not stop at a stop sign and crashed into the front passenger side of the vehicle. All of the air bags deployed. The contact's boyfriend suffered bruising to the wrist and left upper arm and redness on the right hand. The front passenger-side curtain air bag caused the contact second-degree chemical burn on the right side of the stomach when it burned through two layers of clothing. The contact also suffered from a sprained left foot and left hand and lacerations from the shoulders and elbows from the air bag deployment. The contact and her boyfriend were transported to the hospital via ambulance and received medical attention. A police report was filed. The vehicle was towed to the tow yard but was not yet deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 43,000.
NHTSA ODI #11739351
Mileage unknown · May 10, 2026
Unknown Or Other
I purchased the Ford Explorer in June of 2023. The struts were replaced at 10,400 miles because of this problem. I have tried to work with Ford Customer service and have a case number associated with it XXX . I brought the Explorer in to get it fixed again for the same strut problem. It has 44,600 miles on it. So it’s out…
Read full complaint
I purchased the Ford Explorer in June of 2023. The struts were replaced at 10,400 miles because of this problem. I have tried to work with Ford Customer service and have a case number associated with it XXX . I brought the Explorer in to get it fixed again for the same strut problem. It has 44,600 miles on it. So it’s out of the warranty it 36K miles . Still after working with Ford Customer Relations service they denied any coverage for the repair. They said they don’t cover regular worn parts . Now, I am paying out of pocket $2,097.47. This is a known problem and I feel Ford needs to pay for the repair of the strut . It’s clearly a manufacturer defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11736843
Mileage unknown · May 5, 2026
Structure
Sunroof retractable headliner
NHTSA ODI #11735827
Mileage unknown · Apr 27, 2026
Engine
Ecoboost. Coolant intrusion into cylinder head causing white smoke to come out of the exhaust. This is the second ford vehicle I have owned with the same issue.
NHTSA ODI #11734156
Official recalls
15Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.
Consequence & remedy
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the bezel around the switch as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters explaining the safety risk were mailed August 19, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Lincoln Aviator owner notification letters were mailed August 21, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S52. This recall expands Recall 25V393. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.
Consequence & remedy
Consequence: A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the accessory protocol interface module (APIM) software, free of charge. Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Jul 7, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Jun 13, 2025
Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.
Consequence & remedy
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing their risk of injury.
Remedy: Dealers will inspect the second-row seat switch, and replace the bezel around the switch as necessary, free of charge. Owner notification letters were mailed August 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S67.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 23V-342. The video output may fail, preventing the rearview camera image from displaying.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the Image Processing Module software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S27.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Feb 8, 2024
Ford Motor Company (Ford) is recalling certain 2023 Explorer vehicles. The right-front lower fastener connecting the steering knuckle and strut may be loose or missing.
Consequence & remedy
Consequence: A loose or missing connection between the knuckle and strut can cause improper tire alignment, resulting in a steering pull or require increased steering effort. Additionally, the brake hose may contact the tire and become damaged, resulting in a brake fluid leak and a loss of braking ability. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect the fasteners, and tighten or install them as necessary, free of charge. Owner notification letters were mailed March 08, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S04.
Additional source detail variants (2)
Suspension:front:macpherson Strut
Ford Motor Company (Ford) is recalling certain 2023 Explorer vehicles. The right-front lower fastener connecting the steering knuckle and strut may be loose or missing.
Consequence: A loose or missing connection between the knuckle and strut can cause improper tire alignment, resulting in a steering pull or require increased steering effort. Additionally, the brake hose may contact the tire and become damaged, resulting in a brake fluid leak and a loss of braking ability. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect the fasteners, and tighten or install them as necessary, free of charge. Owner notification letters were mailed March 08, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S04.
Steering:linkages:knuckle:spindle:arm
Ford Motor Company (Ford) is recalling certain 2023 Explorer vehicles. The right-front lower fastener connecting the steering knuckle and strut may be loose or missing.
Consequence: A loose or missing connection between the knuckle and strut can cause improper tire alignment, resulting in a steering pull or require increased steering effort. Additionally, the brake hose may contact the tire and become damaged, resulting in a brake fluid leak and a loss of braking ability. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect the fasteners, and tighten or install them as necessary, free of charge. Owner notification letters were mailed March 08, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S04.
Oct 13, 2023
Ford Motor Company (Ford) is recalling certain 2023 Explorer vehicles equipped with a standard rearview camera. Due to a manufacturing error in the wire harness, the rearview camera may display a blue image on the SYNC screen when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not properly display an image can reduce the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will inspect the rearview camera wire harness and repair any loose splices, free of charge. Owner notification letters were mailed November 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C31.
Additional source detail variants (2)
Back Over Prevention:display Function
Ford Motor Company (Ford) is recalling certain 2023 Explorer vehicles equipped with a standard rearview camera. Due to a manufacturing error in the wire harness, the rearview camera may display a blue image on the SYNC screen when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview camera that does not properly display an image can reduce the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will inspect the rearview camera wire harness and repair any loose splices, free of charge. Owner notification letters were mailed November 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C31.
Electrical System:wiring
Ford Motor Company (Ford) is recalling certain 2023 Explorer vehicles equipped with a standard rearview camera. Due to a manufacturing error in the wire harness, the rearview camera may display a blue image on the SYNC screen when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview camera that does not properly display an image can reduce the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will inspect the rearview camera wire harness and repair any loose splices, free of charge. Owner notification letters were mailed November 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C31.
Aug 25, 2023
Ford Motor Company (Ford) is recalling certain 2023 Explorer vehicles equipped with 2.3L GTDI engines. The turbocharger oil supply line may be damaged, which can result in an oil leak inside the engine compartment.
Consequence & remedy
Consequence: An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire. In addition, the loss of oil can result in an engine stall, increasing the risk of a crash.
Remedy: Owners are advised to park and shut off the engine as soon as possible if they see an oil pressure warning light or smoke coming from the engine compartment. Dealers will replace the turbo oil supply line assembly, free of charge. Owner notification letters were mailed September 8, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S50.
Additional source detail variants (2)
Engine And Engine Cooling:engine:oil/lubrication:pipes, Hoses, And Fittings
Ford Motor Company (Ford) is recalling certain 2023 Explorer vehicles equipped with 2.3L GTDI engines. The turbocharger oil supply line may be damaged, which can result in an oil leak inside the engine compartment.
Consequence: An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire. In addition, the loss of oil can result in an engine stall, increasing the risk of a crash.
Remedy: Owners are advised to park and shut off the engine as soon as possible if they see an oil pressure warning light or smoke coming from the engine compartment. Dealers will replace the turbo oil supply line assembly, free of charge. Owner notification letters were mailed September 8, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S50.
Engine And Engine Cooling:engine:gasoline:turbo/supercharger
Ford Motor Company (Ford) is recalling certain 2023 Explorer vehicles equipped with 2.3L GTDI engines. The turbocharger oil supply line may be damaged, which can result in an oil leak inside the engine compartment.
Consequence: An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire. In addition, the loss of oil can result in an engine stall, increasing the risk of a crash.
Remedy: Owners are advised to park and shut off the engine as soon as possible if they see an oil pressure warning light or smoke coming from the engine compartment. Dealers will replace the turbo oil supply line assembly, free of charge. Owner notification letters were mailed September 8, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S50.
May 12, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will replace the 360-degree camera, free of charge. Owner notification letters were mailed November 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S23. This recall expands and replaces NHTSA recall number 23V-022. Vehicles previously repaired under 23V-022 will need to have the new remedy performed.
Feb 10, 2023
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."
Consequence & remedy
Consequence: The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.
Remedy: Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.
Jan 23, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the image processing module (IPMB) software, free of charge. Interim owner notification letters informing owners of the safety risk were mailed April 25, 2023. Owner notification letters were mailed February 13, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S02. This recall expands and replaces NHTSA recall number 21V-735. Vehicles previously repaired under 21V-735 will need to have the new remedy performed.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration