Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports1 fire reports1 injury reports

Engine And Engine Cooling complaints

1 reports

Clear category filter

9,000 miles · Jun 5, 2025

Engine And Engine Cooling

Read full complaint

The contact owns a 2024 Ford F-250 SD. The contact stated that the DEF (Diesel Exhaust Fluid) system failed to operate as needed while towing heavy loads. The contact stated that the vehicle was equipped with 7,500 miles DEF which was considered full. The contact stated that after traveling for approximately 200 miles, there was a message that there were only 500 miles before DEF was empty. The contact notified a local dealer about the issue, and the DEF tank and sensor were replaced. After the parts were replaced, the system indicated that the DEF system was full at 2,750 miles instead of 7,500 miles. The contact notified the dealer of the issue and was informed that the system would return to the 7500 miles of DEF; however, the system failed to reset. The vehicle was not repaired. The manufacturer was notified of issue and a case was filed. The contact was then referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 9,000.

NHTSA ODI #11665034

Official recalls

26V489000 · Back Over Prevention:display Function; Back Over Prevention:software

Jul 28, 2026

Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence & remedy

Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.

Additional source detail variants (2)

Back Over Prevention:display Function

Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.

Back Over Prevention:software

Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

26V104000 · Electrical System: Integrated Trailer Brake Control; Exterior Lighting:tail Lights

Feb 20, 2026

Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

Additional source detail variants (2)

Exterior Lighting:tail Lights

Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

Electrical System: Integrated Trailer Brake Control

25V315000 · Back Over Prevention:software

May 9, 2025

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

Consequence & remedy

Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.

24V806000 · Back Over Prevention: Sensing System: Camera; Structure:body:tailgate

Oct 25, 2024

Ford Motor Company (Ford) is recalling certain 2023-2024 F-250, F-350, and F-450 vehicles. Water may enter the Tailgate Park Assist Sensor Interface Module (TPASIM) and cause the rearview camera image to display intermittently or appear blue or black.

Consequence & remedy

Consequence: A rearview camera image that does not display can decrease the driver's visibility, increasing the risk of injury or crash.

Remedy: Dealers will replace the tailgate top camera, wire harness, TPASIM module, and update the Image Processing Module A (IPMA) software, free of charge. Owner notification letters were mailed August 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S66.

Additional source detail variants (2)

Back Over Prevention: Sensing System: Camera

Consequence: A rearview camera image that does not display can decrease the driver's visibility, increasing the risk of injury or crash.

Remedy: Dealers will replace the tailgate top camera, wire harness, TPASIM module, and update the Image Processing Module A (IPMA) software, free of charge. Owner notification letters were mailed August 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S66.

Structure:body:tailgate

Consequence: A rearview camera image that does not display can decrease the driver's visibility, increasing the risk of injury or crash.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.