Service Brakes. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports0 fire reports0 injury reports

Service Brakes complaints

5 reports

Clear category filter

Mileage unknown · Feb 18, 2026

Service Brakes

Read full complaint

I have about 6,000 miles on the vehicle which was purchased new. There were 2 incidents prior to 2/15/26 (the 3rd incident), but it was only this 3rd incident whereby I could identify the problem. The 2 early incidents I only experienced the smell of burning rubber when driving and exiting the vehicle. Which, i couldn't fathom where it was coming from. And, there was probably a month between incidents. This latest 2/15/26 incident, I was driving and started smelling rubber again, but now I happened to have my fuel mileage indicator on and saw my fuel indicator drop from it's normal average of 17mpg to about 6 mpg. I immediately suspected the parking brake had independently engaged but there was no light or any indication of that on my dashboard screen. I pulled over, turned the engine off, got out and smelt strong scent of rubber burning. While standing next to the vehicle (the engine is off mind you) and making a note of this event on my phone, I heard hydraulics start and stop underneath the truck . That made me suspect the parking brakes even more. I got in, started up, and drove. All was back to normal, no more burning rubber or bad mileage. There's a software glitch PROBLEM here and I have to believe I'm not the only one! After this, I'll be reaching out to Ford to see what they're going to do.

NHTSA ODI #11718907

Mileage unknown · Jan 6, 2026

Service Brakes

When backing up the brakes will lockup

NHTSA ODI #11709192

Mileage unknown · Dec 19, 2025

Service BrakesSteering

Read full complaint

When I was pulling out of the gas station parking lot on Dec 15th, 2025, I pressed the gas and heard a noise that sounded like high RPMs. I then approached the intersection and attempted to press the brake and the brake would not press in, it was hard. My truck then continued to move forward. I attempted to turn the steering wheel as a truck was coming at me. The steering wheel would not turn or move at all. I was stuck in the middle of an intersection after it rolled to a stop. I turned on my flashers and looked at the dashboard to make sure my truck was in drive, which it was. A message was also displayed on the dashboard. It said accessory mode. I could hear my truck running. I cleared the message by pressing the ok button on the steering wheel. I put it in park and then into drive and the same message displayed again on the dashboard. I decided to turn off my truck and pressed the push button to turn it off (my foot was off the brake as I don’t need to press the brake to turn my truck off) and the starter engaged and I put the truck in drive and was able to press the brake and turn the steering wheel. I slowly drove the short distance home and called my husband which he instructed me to call Evansville Ford in Evansville, WI and had my truck towed there. Obviously, not having steering or brakes is a HUGE safety issue. Less than 24 hours earlier I had my entire family in that truck driving on the interstate. I can’t image that we would be alive if I had lost brakes and steering on the interstate. As of Dec 19th 2025, Evansville Ford has stated that they cannot find any issues, nor replicate the problem and returned my truck. My truck is currently available for inspection at my residence.

NHTSA ODI #11706147

Mileage unknown · Jul 21, 2025

Service Brakes

Read full complaint

I purchased a brand-new 2025 Ford F-250 Super Duty on April 1, 2025. The truck has an intermittent and ongoing issue where the dashboard displays “Park Brake Limited Function” or “Park Brake Service Required.” I took the vehicle to the authorized Ford dealer, but they told me the problem cannot be repaired. However, when I contacted Ford corporate customer service, they claimed the issue is known and can be repaired, and referred me to safety department complain This contradiction between Ford and the dealer is unacceptable. The issue affects the functionality and safety of the vehicle, and it remains unresolved. I request that NHTSA investigate this issue and pressure Ford to provide a consistent, repairable solution

NHTSA ODI #11675035

Mileage unknown · Jul 12, 2025

Service Brakes

Trailer brake controller was at first intermittently failing with message “trailer disconnected” appearing on dashboard. Now > 2,000 miles trailer brakes are not working. Vehicle was updated with SSM 53889 which did not resolve the issue.

NHTSA ODI #11673057

Official recalls

26V489000 · Back Over Prevention:display Function; Back Over Prevention:software

Jul 28, 2026

Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence & remedy

Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.

Additional source detail variants (2)

Back Over Prevention:display Function

Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.

Back Over Prevention:software

Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

26V119000 · Power Train:axle Assembly:axle Shaft

Mar 3, 2026

Ford Motor Company (Ford) is recalling certain 2026-2025 F-250 SD and F-350 SD vehicles. The driveshaft friction weld may fail, resulting in rear driveshaft separation and a sudden loss of drive power.

Consequence & remedy

Consequence: A loss of drive power can increase the risk of a crash.

Remedy: Dealers will inspect the driveshaft serial number and replace the driveshaft as necessary, free of charge. Owner notification letters were mailed April 6, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S13. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.

26V104000 · Electrical System: Integrated Trailer Brake Control; Exterior Lighting:tail Lights

Feb 20, 2026

Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

Additional source detail variants (2)

Exterior Lighting:tail Lights

Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

Electrical System: Integrated Trailer Brake Control

25V540000 · Electrical System: Instrument Cluster/panel

Aug 22, 2025

Ford Motor Company (Ford) is recalling certain 2025-2026 F-550 SD, F-450 SD, F-350 SD, F-250 SD, and 2025 F-150 vehicles. The Instrument Panel Cluster (IPC) may fail at startup.

Consequence & remedy

Consequence: An instrument panel display that does not show critical information, such as warning lights or vehicle speed, increases the risk of a crash.

Remedy: The instrument panel cluster software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed September 5, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S88.

25V401000 · Service Brakes, Hydraulic:pedals And Linkages

Jun 13, 2025

Ford Motor Company (Ford) is recalling certain 2025 F-550 SD, F-450 SD, F-350 SD, and F-250 SD vehicles. The brake booster pushrod retaining spring may not have been installed, which can allow the pushrod to disconnect from the brake pedal and cause a sudden loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 135, "Light Vehicle Brake Systems" and 105, "Hydraulic and electric brake systems."

Consequence & remedy

Consequence: A sudden loss of brake function increases the risk of a crash.

Remedy: Owners are advised not to drive their vehicles until they have been repaired. Dealers will inspect and repair the brake pedal assembly as necessary, free of charge. Owner notification letters were mailed June 20, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 25C26.

25V306000 · Fuel System, Diesel:delivery:hoses, Lines/piping, And Fittings

May 9, 2025

Ford Motor Company (Ford) is recalling certain F-250 and F-350 vehicles. Cracked fuel return line connectors may leak fuel into the engine compartment.

Consequence & remedy

Consequence: A fuel leak in the presence of an ignition source such as hot engine components, can increase the risk of a fire.

Remedy: Dealers will replace the fuel return lines, free of charge. All vehicles have been repaired. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 25S44.

25V163000 · Power Train:automatic Transmission:gear Position Indication (prndl)

Mar 14, 2025

Ford Motor Company (Ford) is recalling certain 2025 Super Duty F-250, F-350, and F-450 vehicles. The steering column shifter may have been improperly welded and detach from the steering column.

Consequence & remedy

Consequence: A detached shifter will prevent the driver from shifting into park, which can result in a vehicle rollaway and increase the risk of a crash.

Remedy: Dealers will inspect the steering column serial numbers and replace the steering column as necessary, free of charge. Owner notification letters were mailed April 28, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S20.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.