Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 13 of 86 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports1 fire reports7 injury reports
What owners actually said
86 reports
Mileage unknown · Jun 9, 2026
Steering
Vehicle Information: •Year/Make/Model: [2022, Honda HR-V •VIN (17 digits): [[XXX] •Current Mileage: 22000 Miles Description of Safety Defect: The electronic power steering system suffers from a severe defect causing the steering wheel to seize, bind, and freeze completely locked while the vehicle is in motion. This binding defec…
Read full complaint
Vehicle Information: •Year/Make/Model: [2022, Honda HR-V •VIN (17 digits): [[XXX] •Current Mileage: 22000 Miles Description of Safety Defect: The electronic power steering system suffers from a severe defect causing the steering wheel to seize, bind, and freeze completely locked while the vehicle is in motion. This binding defect causes a sudden, unpredictable loss of steering control, forcing the driver to struggle with the wheel or wait for the system to loosen, presenting an extreme, imminent risk of a motor vehicle crash, injury, or death. Chronological Incident Summary: Over the last six months, the steering wheel on this vehicle has frozen completely while driving on four separate occasions. The incidents occurred under normal driving conditions at varying speeds. During each occurrence, the steering wheel momentarily locked tight, resisting all manual steering input. The vehicle did not provide any electronic warning lights or dashboard errors prior to or during the failures. Control was only regained after forcefully wrestling with the wheel or, in some cases, safely pulling over to restart the vehicle engine. Manufacturer/Dealer Action: The vehicle was taken to an authorized Honda dealership to address this catastrophic safety failure. However, the service department refused to acknowledge the issue, stating they could not replicate the malfunction and declined to perform any diagnostic repairs. Public Context & Recall Relevance: This defect perfectly replicates the failure mode thoroughly documented under NHTSA Recall Campaign 24V744000 for "sticky steering" and binding gearboxes in 2023–2025 Honda HR-V models. Despite widespread online consumer reports and thousands of matching manufacturer warranty claims for the exact same steering gearbox swelling issue, the dealer has failed to provide the necessary remedy. I am filing this complaint because the manufacturer's denial of this known defect leaves an inherently dangerous vehicle on public INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC
NHTSA ODI #11743012
Mileage unknown · May 30, 2026
Electrical SystemEnginePower Train
The vehicle has a recurring safety defect where it suddenly shuts off / stalls while driving. This has happened multiple times, including immediately after the dealership performed repairs and issued "clean" diagnostic reports stating no issues were found. Key details: PCU codes were present on the first visit but were not pro…
Read full complaint
The vehicle has a recurring safety defect where it suddenly shuts off / stalls while driving. This has happened multiple times, including immediately after the dealership performed repairs and issued "clean" diagnostic reports stating no issues were found. Key details: PCU codes were present on the first visit but were not properly addressed. Repair orders contain clear inconsistencies, including claims of test drives and mileage that do not match the actual odometer readings. On the most recent visit, I did not authorize any further repairs, yet the dealership now claims the vehicle is "resolved" and ready for pickup. The vehicle has been at Honda dealerships for a total of 57 days across multiple failed repair attempts. I have refused to take possession of the vehicle due to the ongoing safety risk of it shutting off while driving.
NHTSA ODI #11741009
Mileage unknown · Apr 14, 2026
Forward Collision Avoidance
Since purchasing my 2022 Honda HR-V in 2024, I have experienced ongoing unintended or “phantom” braking while driving at highway speeds with adaptive cruise control, lane keeping assist, and the Collision Mitigation Braking System activated. When a vehicle is traveling in an adjacent lane—most frequently on the right side—the da…
Read full complaint
Since purchasing my 2022 Honda HR-V in 2024, I have experienced ongoing unintended or “phantom” braking while driving at highway speeds with adaptive cruise control, lane keeping assist, and the Collision Mitigation Braking System activated. When a vehicle is traveling in an adjacent lane—most frequently on the right side—the dashboard displays an orange brake warning, and the vehicle abruptly brakes without driver input despite no obstruction in my lane. This issue occurs approximately four times per week, and the vehicle currently has about 75,000 miles. During each incident, I disengage adaptive cruise control using the steering wheel controls to regain manual control. Although no accidents or injuries have occurred, these sudden braking events have resulted in multiple near-miss situations and present a significant safety concern.
NHTSA ODI #11731268
Mileage unknown · Apr 6, 2026
Steering
Subject: Safety Defect Report – Steering Wheel Lock-Up & Lack of Notification – 2022 Honda HR-V Description of Incident: I am reporting a severe, life-threatening safety defect regarding the steering system of my 2022 Honda HR-V. While driving, the steering wheel suddenly and unexpectedly locks up, making it nearly impossible t…
Read full complaint
Subject: Safety Defect Report – Steering Wheel Lock-Up & Lack of Notification – 2022 Honda HR-V Description of Incident: I am reporting a severe, life-threatening safety defect regarding the steering system of my 2022 Honda HR-V. While driving, the steering wheel suddenly and unexpectedly locks up, making it nearly impossible to steer. This has occurred more than three times recently, with increasing frequency. Key Safety Concerns: •Sudden Loss of Control: The steering becomes rigid without warning, creating an immediate risk of a crash. This has occurred during each of my last three trips. •Lack of Manufacturer Notification: According to official NHTSA Recall 24V-744, the "sticky steering" gearbox recall includes certain 2022–2025 Honda models. However, I never received a recall notice for my vehicle. •Contradictory Information: My research confirms that the 2022 model year and the HR-V model are specifically named in the broad recall for this steering gearbox defect. Despite my vehicle exhibiting the exact "sticky" and locking behavior identified in the recall, I have not been contacted by Honda for the free repair. •Manufacturer Acknowledgment: Both my local dealer and Honda corporate have confirmed that 2023 and newer models are being recalled, yet my 2022 model—built within the same production window and using the same faulty supplier parts—is not being prioritized for service. Request for Action: I request that NHTSA investigate why 2022 HR-V models experiencing these dangerous failures were not included in the primary notification mailing. I urge NHTSA to ensure that all 2022 HR-V owners experiencing this steering gearbox failure are granted access to the free repair (gearbox or worm gear spring replacement) Google Search Yes, a significant "sticky steering" issue affecting nearly 1.7 million Honda and Acura vehicles from the 2022–2025 model years is being addressed through a massive NHTSA recall (Campaign 24V-744), initiated in October 2024. The de
NHTSA ODI #11729377
Mileage unknown · Mar 29, 2026
Power Train
I bought the car at the dealership with 50,000 miles on it and purchased an extended warranty as well. I drive for a living with this car and after a few months noticed it would rev high before shifting. When I brought it back to the dealership they did something to it but did not say what. It smelled like they put catalyst clea…
Read full complaint
I bought the car at the dealership with 50,000 miles on it and purchased an extended warranty as well. I drive for a living with this car and after a few months noticed it would rev high before shifting. When I brought it back to the dealership they did something to it but did not say what. It smelled like they put catalyst cleaner in it though not confirmed. I then had the issue again and the car smelled like burning rubber. I took it to a honda dealership and had the transmission fluid as well as the rear differential fluid changed but they did could not find any issues. Now that my warranty has run out and I have over 150,000 I had a tire shop where I was buying new tires inform me that the rear differential carrier bracket bushings were in need of being replaced as soon as possible. I could not afford for them to do it for me. I have researched online and have found this very well could have been the problem with the shifting and rubber smell the entire time. My car was under warranty and now it is not. Why is Honda not replacing this to prevent even bigger failure and repair issues. My son owns a 2019 Honda C RV as well and he says his car is experiencing the exact same issue.
NHTSA ODI #11727772
Mileage unknown · Mar 23, 2026
Power Train
I am reporting a transmission failure in my 2022 Honda HR-V at approximately 129,000 miles. While driving on the interstate highway at normal speed, the vehicle suddenly began revving excessively without accelerating. The engine RPM increased, but the vehicle failed to maintain proper speed or respond as expected. This occurred…
Read full complaint
I am reporting a transmission failure in my 2022 Honda HR-V at approximately 129,000 miles. While driving on the interstate highway at normal speed, the vehicle suddenly began revving excessively without accelerating. The engine RPM increased, but the vehicle failed to maintain proper speed or respond as expected. This occurred without any prior warning signs or indicators. Shortly after, the vehicle continued to have issues where it would shift into gear but not properly move or engage. All dashboard warning lights became illuminated following the incident. I took the vehicle to a dealership for diagnosis, and they confirmed that the transmission is failing. They reported finding metal shavings inside the transmission, indicating internal mechanical damage and premature wear. This sudden loss of power and inability to accelerate properly while driving at highway speeds created a serious safety hazard. The vehicle could have been rear-ended or caused an accident due to the unexpected loss of performance. A major component like the transmission should not fail in this manner, especially without warning, as it poses a significant safety risk to the driver and others on the road.
NHTSA ODI #11726506
Mileage unknown · Mar 9, 2026
Unknown Or Other
My transmission went before the car hit 100 thousand miles. It put me at risk because I was in the middle of the road and my car wouldn’t move. The problem was confirmed by the Honda dealer. There were zero warning signs before this happened.
NHTSA ODI #11723081
Mileage unknown · Mar 6, 2026
EngineUnknown Or Other
I've been the only owner to this 22' Honda HRV and I have serviced it at the dealer 90% of the time. All oil changes, coolant flush, transmission services etc. done on time. I recently got it diagnosed at my local Honda dealer because it was starting to make a noise when you stepped on the gas. The noise started at about 95k mil…
Read full complaint
I've been the only owner to this 22' Honda HRV and I have serviced it at the dealer 90% of the time. All oil changes, coolant flush, transmission services etc. done on time. I recently got it diagnosed at my local Honda dealer because it was starting to make a noise when you stepped on the gas. The noise started at about 95k miles and becomes louder as you increase the speed of the vehicle. The dealer diagnosed it with an internal transmission failure. There were no warning lights or messages ever. No prior check engine lights on or mechanical issues prior to this. I am very disappointed with this vehicle. Hopefully this issue is looked into. I do not hope for this to happen to anyone with this vehicle.
NHTSA ODI #11722529
Mileage unknown · Feb 28, 2026
Electrical SystemUnknown Or Other
I am writing to formally report a recurring safety defect regarding the infotainment system in my 2022 Honda HR-V. For over a month, the system has remained completely non-functional (blank screen). Prior to this total failure, the unit exhibited intermittent power cycles since the date of purchase around February 2024. Upon in…
Read full complaint
I am writing to formally report a recurring safety defect regarding the infotainment system in my 2022 Honda HR-V. For over a month, the system has remained completely non-functional (blank screen). Prior to this total failure, the unit exhibited intermittent power cycles since the date of purchase around February 2024. Upon inspection by an authorized Honda dealership, technicians confirmed that this is a known computer hardware issue frequent in this model year. Despite their admission that they "see this a lot," there is currently no active recall to address the defect. Safety Implications This failure is not merely a convenience issue; it creates several significant safety hazards: • Loss of Driver Assistance: The rearview camera and LaneWatch™ camera are completely disabled, significantly increasing the risk of collisions during reversing or lane changes. • Distracted Driving: I am unable to use integrated navigation, forcing reliance on handheld devices for directions. • Emergency Communication: The internal USB ports have failed along with the unit, preventing phone charging. This leaves me at risk of having no communication during a roadside emergency or breakdown. Evidence I have documented video evidence of a certified Honda technician stating that this is a pervasive and "very common" issue with this vehicle's architecture. I urge the association to investigate these systemic failures. A safety-critical component like the rearview camera should not be subject to such widespread hardware instability without a manufacturer-led remedy.
Honda (America Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles that were previously recalled under NHTSA recall number 23V-046. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed July 8, 2024. Owners may contact Honda service at 1-888-234-2138. Honda's numbers for this recall are TIQ and DIR. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed.
Additional source detail variants (2)
Back Over Prevention:software
Honda (America Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles that were previously recalled under NHTSA recall number 23V-046. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed July 8, 2024. Owners may contact Honda service at 1-888-234-2138. Honda's numbers for this recall are TIQ and DIR. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed.
Back Over Prevention:display Function
Honda (America Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles that were previously recalled under NHTSA recall number 23V-046. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed July 8, 2024. Owners may contact Honda service at 1-888-234-2138. Honda's numbers for this recall are TIQ and DIR. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed.
Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.
Consequence & remedy
Consequence: An air bag that deploys unintentionally during a crash can increase the risk of injury.
Remedy: Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed March 13, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is 6DW. This recall has been superseded by NHTSA recall number 24V-384. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed under recall 24V-384.
Additional source detail variants (2)
Back Over Prevention:display Function
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed March 13, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is 6DW. This recall has been superseded by NHTSA recall number 24V-384. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed under recall 24V-384.
Back Over Prevention: Sensing System: Camera
Honda (American Honda Motor Co.) is recalling certain 2018-2020 Fit and 2019-2022 HR-V vehicles. The rearview camera image may not display when the engine is started with a key, due to a design error in the audio display power circuit. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: An inoperative rearview camera display can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the display audio unit software, free of charge. Owner notification letters were mailed March 13, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is 6DW. This recall has been superseded by NHTSA recall number 24V-384. Vehicles previously repaired under recall 23V-046 will need to have the new remedy completed under recall 24V-384.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE22011 · Rear Differential Seizure
Opened Nov 28, 2022 · Closed Jul 22, 2024
Status: closed (inferred from source dates) · Power Train; Power Train:axle Assembly; Power Train:axle Assembly:axle Shaft; Power Train:axle Assembly:axle Shaft:seal; Power Train:driveline:differential Unit; Power Train:driveline:driveshaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Additional source detail variants (6)
Power Train:axle Assembly:axle Shaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:axle Assembly:axle Shaft:seal
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:axle Assembly
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:driveline:differential Unit
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train:driveline:driveshaft
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
Power Train
On November 29, 2022, the Office of Defects Investigation (ODI) opened PE 22-011 after reviewing field reports alleging rear differential seizure in 2018-2022MY Honda CR-V and HR-V vehicles equipped with all wheel drive. To date, ODI has not received any consumer complaints. Some of the field reports received alleged the vehicle’s wheels locked up with no warning while the vehicle was in motion. These vehicles were towed to a dealership. Examination of these vehicles showed the driveshaft had broken and the differential unit was completely damaged. The field reports cited a lack of oil due to damaged oil seals as the cause. Honda provided data including consumer complaints, field reports, and warranty claims they received relating to the loss of oil retention and resulting differential damage. Honda’s data cited 1201 incidents with unique vehicle identification numbers (VINs). The rear differential oil seals prevent the oil from leaking out and protect internal components from contaminants. A loss of oil lubrication results in failure of the vehicle differential. Honda stated that the oil seal’s lip contact with the driveshaft may become unstable due to intermittent changes in internal pressure. Their review of field report and warranty data indicated that these failures occurred early in the vehicle’s life thus the failures were covered by the manufacturer’s warranty. Honda stated that in November 2021 they changed the seal specifications and improved the packaging process of the parts for transport. Honda also enacted an enhanced visual inspection process both before and after the oil seal installation on the assembly line. Honda stated that in the event of differential failure, the operator can control the vehicle without stability loss. After the drive shafts break due to differential failure, the operator will hear noises and the vehicle will still function as a 2WD vehicle preventing complete loss of motive power. Based on the following factors, ODI is closing this investigation: · Information regarding field failures does not indicate hazardous outcomes · The failures are occurring early in the life of the vehicle · Repairs are covered under the manufacturer’s warranty · The vehicle can continue functioning as a 2WD without loss of stability control in the event of failure The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.
2022 Honda HR-V Problems, Complaints & Recalls | Skip That Year
Illustration