IllustrationLEXUS RX400H 2006 - ABS - WHEN APPLYING BRAKES TO SLOW DOWN, IF THE CAR IS ON A BUMPY ROAD, THE BRAKES SEEM TO GIVE OUT AND THE CAR LUNGES FORWARD. THIS SEEMS TO HAPPEN AS CAR SWITCHES FROM REGENERATIVE BRAKING TO REGULAR BRAKES. I HAVE REPORTED THIS ISSUE TO THE DEALER SEVERAL TIMES, AND THEY HAVE YET TO FIND ANY PROBLEM. *TR
2006 Lexus Rx Hybrid
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Rx Hybrid years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
230–25K
1825–50K
2650–75K
2075–100K
40100–150K
11150K+
138 reports with mileage · 16 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports0 fire reports5 injury reports
Service Brakes, Electric complaints
13 reportsI HAVE A 2006, LEXUS, RX 400 H. A LEXUS CERTIFIED USED VEHICLE. THE VEHICLE WAS NEW TO ME LAST SUMMER. IT ACCELERATES SLIGHTLY WHEN I INITIATE BRAKING 2 OR 3 TIMES OUT OF 20 TIMES. I THOUGHT IT WAS "NORMAL" FOR A CAR WITH REGENERATIVE BRAKING. IT STARTLES YOU WHEN IT HAPPENS BUT HARD PRESSURE ON THE BRAKE STOPS THE CAR. YOU HAVE…
Read full complaint
I HAVE A 2006, LEXUS, RX 400 H. A LEXUS CERTIFIED USED VEHICLE. THE VEHICLE WAS NEW TO ME LAST SUMMER. IT ACCELERATES SLIGHTLY WHEN I INITIATE BRAKING 2 OR 3 TIMES OUT OF 20 TIMES. I THOUGHT IT WAS "NORMAL" FOR A CAR WITH REGENERATIVE BRAKING. IT STARTLES YOU WHEN IT HAPPENS BUT HARD PRESSURE ON THE BRAKE STOPS THE CAR. YOU HAVE TO PAY ATTTENTION EACH TIME YOU BRAKE. WHAT IS SCARY IS IT ACCELERATES A LOT IN ABOUT 1 OF 100 TIMES WHEN I BRAKE. AT FIRST I THOUGHT I WAS HITTING BOTH THE GAS AND THE ACCELERATOR ... BUT I AM SURE I AM NOT. THE CAR WILL ACCELERATE TWO CAR LENGTHS BEFORE YOU CAN BRAKE IT. I THOUGHT IT WAS DANGEROUS AND BROUGHT IT TO THE DEALER LAST YEAR. WE WENT FOR A TEST DRIVE AND THE PROBLEM DID NOT OCCUR. THE DEALERSHIP RECORDED THE COMPLAINT AND TOLD ME TO KEEP AN EYE ON IT. THE 2 CAR LENGTH ACCELERATION PROBLEM WAS WORSE IN THE HOT MONTHS AND IT DID NOT SEEM TO OCCUR IN THE WINTER MONTHS. THE SLIGHT ACCELERATION PROBLEM HAS NOT CHANGED IN FREQUENCY. WITH ALL THIS TOYOTA BRAKE STUFF, I WONDER WHY I HAVE NOT HEARD OF THIS PROBLEM IN LEXUS HYBRID CARS TOO?
WE OWN A 2006 LEXUS RX 400H AND OCCASIONALLY WHEN THE BRAKES ARE PRESSED THE CAR 'JUMPS' FORWARD. WE HAVE TAKEN OUR VEHICLE TO THE LEXUS DEALERSHIP SEVERAL TIMES TO REPORT THE ISSUE BUT THEY ALWAYS RETURN AND TELL US NOTHING IT WRONG WITH THE VEHICLES BRAKING SYSTEM. THIS EVENT DOES NOT OCCUR ALL THE TIME, WE ARE CONCERNED THA…
Read full complaint
WE OWN A 2006 LEXUS RX 400H AND OCCASIONALLY WHEN THE BRAKES ARE PRESSED THE CAR 'JUMPS' FORWARD. WE HAVE TAKEN OUR VEHICLE TO THE LEXUS DEALERSHIP SEVERAL TIMES TO REPORT THE ISSUE BUT THEY ALWAYS RETURN AND TELL US NOTHING IT WRONG WITH THE VEHICLES BRAKING SYSTEM. THIS EVENT DOES NOT OCCUR ALL THE TIME, WE ARE CONCERNED THAT IF WE ARE REQUIRED TO STOP SUDDENLY TO AVOID AN ACCIDENT, ETC. THAT OUR VEHICLE WILL JUMP AND WE WILL CAUSE AN ACCIDENT. *TR
BRAKE SLIPPAGE ON 2006 LEXUS RX400H - I BOUGHT THIS NEW IN 2005 AND EVER SINCE THEN, WE'VE SEEN THE SAME KIND OF BRAKE SLIPPAGE THAT OTHER OWNERS HAVE BEEN REPORTING. WHEN WE'RE BRAKING TO COME TO A STOP, THE VEHICLE WILL SUDDENLY LUNGE AS IF THE BRAKES STOPPED GRABBING OR SLIPPED. THE CAR DOES COME TO A STOP WITH CONTINUED PR…
Read full complaint
BRAKE SLIPPAGE ON 2006 LEXUS RX400H - I BOUGHT THIS NEW IN 2005 AND EVER SINCE THEN, WE'VE SEEN THE SAME KIND OF BRAKE SLIPPAGE THAT OTHER OWNERS HAVE BEEN REPORTING. WHEN WE'RE BRAKING TO COME TO A STOP, THE VEHICLE WILL SUDDENLY LUNGE AS IF THE BRAKES STOPPED GRABBING OR SLIPPED. THE CAR DOES COME TO A STOP WITH CONTINUED PRESSURE BUT THE SUDDEN FEELING OF ACCELERATION IS MOST DISCONCERTING. I TAKE IT TO THE DEALER FOR ALL SCHEDULED MAINTENANCE AND EACH TIME I'M THERE, I MENTION THE BRAKING ISSUE. AND, EACH TIME, THEY TELL ME THAT ITS NORMAL FOR THE TYPES OF BRAKES USED IN THE HYBRID TECHNOLOGY. *TR
I OWN A 2006 LEXUS RX400H WHICH I BELIEVE HAS EXACTLY THE SAME FLAW AS RECENTLY REPORTED IN THE PRIUS. SEVERAL YEARS AGO I HAD A MINOR ACCIDENT CAUSED BY MY CAR LURCHING FORWARD DURING BREAKING WHICH CAUSED ME TO HIT THE CAR IN FRONT OF ME. WHEN I BROUGHT MY CAR INTO THE LEXUS OF WATERTOWN DEALERSHIP WHERE I PURCHASED THE VEHI…
Read full complaint
I OWN A 2006 LEXUS RX400H WHICH I BELIEVE HAS EXACTLY THE SAME FLAW AS RECENTLY REPORTED IN THE PRIUS. SEVERAL YEARS AGO I HAD A MINOR ACCIDENT CAUSED BY MY CAR LURCHING FORWARD DURING BREAKING WHICH CAUSED ME TO HIT THE CAR IN FRONT OF ME. WHEN I BROUGHT MY CAR INTO THE LEXUS OF WATERTOWN DEALERSHIP WHERE I PURCHASED THE VEHICLE I REPORTED THAT I THOUGHT THE ISSUE MIGHT BE RELATED TO THE TRANSITION BETWEEN THE REGENERATIVE BRAKING SYSTEM AND THE REGULAR BRAKE. IT SEEMED LIKE THE REGENERATIVE BRAKING SYSTEM WAS TURNED OFF SLIGHTLY BEFORE THE REGULAR BRAKING SYSTEM KICKED IN CAUSING A GAP IN THE BRAKING THAT WAS PERCEIVED BY ME TO BE A "LURCHING FORWARD". OF COURSE, WHAT IT WAS A DECREASE IN DECELERATION THAT APPEARED BE ACCELERATION. IN ANY EVENT, THE DEALER SAID HE CHECKED THE BRAKES AND COULD NOT FIND ANYTHING WRONG. I WOULD SAY FROM THAT TIME UNTIL NOW I HAD ABOUT ONE OR TWO INSTANCES OF THIS LURCHING PER MONTH. I AM VERY USED TO HYBRIDS AND CURRENTLY OWN A PRIUS AS WELL, SO I KNOW THE IDIOSYNCRATIC NATURE OF THE BRAKING SYSTEM. HOWEVER, AFTER THE RECENT CASCADE OF REPORTS ON PROBLEMS WITH THE PRIUS I CALLED MY DEALER AGAIN AND TOLD THEM, YOU SHOULD KNOW THAT THE LEXUS HAS THE SAME PROBLEM, I HAVE HAD EXACTLY THE SAME PROBLEM WITH MY LEXUS HAVE THERE BEEN ANY OTHER REPORTS OF PROBLEMS. I BELIEVE I WAS TOLD NO, HOWEVER, THE WORDING OF THE ANSWER WAS GUARDED. TODAY, I HAD ANOTHER LURCHING EVENT. APPROACHING A STOP SIGN, ON A SMOOTH, DRY ROAD I LURCHED FORWARD AT APPROXIMATELY 15 MPH. IF A PEDESTRIAN WERE CROSSING THE STREET AT THE TIME I WOULD HAVE HIT THEM, CAUSING SERIOUS INJURY, HOPEFULLY NOT DEATH. THIS IS A DANGEROUS SITUATION. I CONTACTED MY LEXUS DEALER TO RELAY THIS ISSUE TODAY AND SAY WE MUST DO THE RIGHT THING. THEY DID NOT RESPOND, SO I AM MOVING FORWARD WITH THIS FORMAL COMPLAINT BEFORE MORE SERIOUS HARM IS DONE. *TR
BRAKES SLIP ON MY LEXUS 400 HYBRID SUV, 2006 MODEL. THIS OCCASIONAL SLIPPAGE HAS ALWAYS BEEN A PART OF THIS CAR SINCE I BOUGHT IT. I HAVE BROUGHT IT TO THE DEALERS ATTENTION AND THEY SAY THEY COULD NOT FIND ANYTHING WRONG. THESE INCIDENTS HAVE CONTINUED TO HAPPEN FROM 2006 PURCHASE DATE UNTIL THE PRESENT, 2010. *TR
I OWN 2 2006 LEXUS RX 400 H HYBRID SUV'S. FROM THE FIRST WEEK I COMPLAINED THAT THE BRAKES WOULD NOT ALWAYS ENGAGE WHEN YOU DEPRESSED THE BRAKE PEDAL. THE CAR WOULD LURCH FORWARD WHEN THE BRAKES DID NOT ENGAGE FOR 1 OR 2 SECONDS. THE LEXUS DEALER HAS DISMISSED MY COMPLAINT EACH TIME. NOW THERE APPEARS TO BE A VOLUNTARY RECAL…
Read full complaint
I OWN 2 2006 LEXUS RX 400 H HYBRID SUV'S. FROM THE FIRST WEEK I COMPLAINED THAT THE BRAKES WOULD NOT ALWAYS ENGAGE WHEN YOU DEPRESSED THE BRAKE PEDAL. THE CAR WOULD LURCH FORWARD WHEN THE BRAKES DID NOT ENGAGE FOR 1 OR 2 SECONDS. THE LEXUS DEALER HAS DISMISSED MY COMPLAINT EACH TIME. NOW THERE APPEARS TO BE A VOLUNTARY RECALL OF TOYOTA HYBRIDS AND ONE LINE OF LEXUS HYBRIDS WITH THE IDENTICAL PROBLEM. BUT THE PROBLEM IS NOT JUST WITH THEIR NEW S50 LEXUS HYBRID. IT HAS EXISTED AT LEAST AS FAR BACK AS 2006 WITH MY CARS. *TR
I WENT TO THE DEALERSHIP LAST MORNING OF FEB 3 2010 FOR MY REGULAR SERIVICE. I DIDN'T KNOW YET THAT TIME ABOUT THE STORY BEHIND THE BREAK TIME LAG OF PRIUS. BECAUSE THAT DAY I TOLD LEXUS TO TAKE A LOOK ON MY BRAKE AS I AM HAVING THE SAME PROBLEM AS THE PRIUS. MY CAR IS A RX400H 2006 MODEL. NOT ONLY I'M HAVING THE SAME PROB…
Read full complaint
I WENT TO THE DEALERSHIP LAST MORNING OF FEB 3 2010 FOR MY REGULAR SERIVICE. I DIDN'T KNOW YET THAT TIME ABOUT THE STORY BEHIND THE BREAK TIME LAG OF PRIUS. BECAUSE THAT DAY I TOLD LEXUS TO TAKE A LOOK ON MY BRAKE AS I AM HAVING THE SAME PROBLEM AS THE PRIUS. MY CAR IS A RX400H 2006 MODEL. NOT ONLY I'M HAVING THE SAME PROBLEM DURING SLOW MOVEMENT(APPROACHING THE TRAFFIC LIGHT) BUT EVEN ON A HIGH SPEED(60-65). I COMPALAIN THE PROBLEM TO LEXUS 3 YEARS AGO AND THEY DID SOME ADJUSTMENT(I DON'Y KNOW WHAT EXACTLY IS) BUT STILL I ALWAYS HAVE THAT PROBLEM AT LEAST ONCE OR TWICE A MONTH. MYWIFE IS THE ONE WHO DRIVES THAT CAR A LOT, AND SHE TOLD ME THAT SHE NEVER HAVE THAT EPISODE ON A HIGH SPEED, BUT SHE SAID SHE ALWAYS HAVE THAT ON A 50MPH SPEED ON A LOCAL STRRET, WHICH IS EVEN WORST, AS THE CAR IN FRONT OF YOU ARE VERY CLOSE. ACTUALY LAST FEB 3 2010 THE LEXUS GAVE ME A LOANER CAR FOR THAT DAY AND IT IS A HS HYBRID CAR(450 MILES) AND IT'S ALMOST NEW, AND I WAS SURPRISED THAT IT HAS THE SAME PROBLEM WHEN I'M APPROACHING THE TRAFFIC LIGHT. SO I TOLD MYSELF, IS THIS NORMAL TO A HYBRID? MY RX400H IS NOW 4 YEARS AND I CANNOT REMEMBER I'M HAVING THAT PROBLEM ON IT'S 1ST YEAR. I BELIEVE THE SLOW SPEED WAS STARTED A MONTH AGO.(MID JAN 2010) AND THE HIGH SPEED IS PROBABLY 3 YEARS NOW. THIS MESSAGE IS NOT A COMPLAIN, BUT RATHER THEM(TOYOTA) TO INVESTIGATE IF EVERYTHING IS STILL NORMAL. *CN
MY LEXUS RX400 H HYBRID VEHICLE IS EXPERIECING SMILAR PROBLEM REGARDING THE BREAK LIKE TOYOTA PRIUS . WHEN BUMPY , DOWN HILL AND ICE ROAD, THE BRAKE WILL EXPERIENCE TEMPORARY DISABLE AND THE CAR WILL MOVE FORWARD.WHEN BRAKING ON UNEVEN OR SLIPPERY SURFACES, THE BRAKING SYSTEM GETS CONFUSED AND BRAKING POWER IS LOST MOMENTARILY.
2006 LEXUS RX 400 AT SLOW SPEEDS STEPS ON BRAKE AND NOTHING HAPPENS FOR ABOUT 2 - 3 SECONDS. THIS HAS NOT CAUSED AN ACCIDENTS AS I HAVE ALLOW ENOUGH SPACE FOR BRAKES TO RESPOND. THIS DOES NOT HAPPEN WITH ANY PATTERN AND IS DIFFICULT TO PREDICT WHEN IT WILL HAPPEN. *TR
Official recalls
513V396000 · Hybrid Propulsion System: Inverter
Sep 4, 2013
Toyota is recalling certain model year 2006-2010 Highlander hybrid vehicles manufactured February 16, 2005, through July 29, 2010; and model year 2006-2008 Lexus RX400h vehicles manufactured February 23, 2005, through December 2, 2008. The Intelligent Power Module (IPM) inside the inverter module may contain transistors that have higher operating temperatures than the solder can support and the transistors may be heat damaged by the solder. If this occurs, various warning lamps, including the malfunction indicator lamp, slip indicator light, brake system warning light, and master warning light, will be illuminated on the instrument panel.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. It is possible that the hybrid system will shut down while the vehicle is being driven, causing the vehicle to stall unexpectedly, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the IPM free of charge. Owners may contact Toyota at 1-800-331-4331. Vehicles that had their IPM replaced under recall 11V-342 are not affected by this campaign.
11V539000 · Engine And Engine Cooling
Nov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
Consequence & remedy
Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
11V342000 · Electrical System
Jun 29, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006-2007 HIGHLANDER HYBRID AND LEXUS RX400H PASSENGER CARS MANUFACTURED FROM FEBRUARY 16, 2005, THROUGH AUGUST 30, 2006. A MODULE INSIDE THE INVERTER MODULE MAY CONTAIN INADEQUATELY SOLDERED TRANSISTORS THAT DURING HIGH-LOAD DRIVING, MAY BE DAMAGED BY HEAT CAUSED BY THE LARGE CURRENT. IF THIS OCCURS, VARIOUS WARNING LAMPS, INCLUDING THE MALFUNCTION INDICATOR LAMP, SLIP INDICATOR LIGHT, BRAKE SYSTEM WARNING LIGHT, AND MASTER WARNING LIGHT, WILL BE ILLUMINATED ON THE INSTRUMENT PANEL.
Consequence & remedy
Consequence: THE VEHICLE MAY ENTER A FAIL-SAFE/LIMP-HOME MODE THAT LIMITS THE DRIVABILITY OF THE VEHICLE. IT IS POSSIBLE THAT THE HYBRID SYSTEM WILL SHUT DOWN WHILE THE VEHICLE IS BEING DRIVEN, CAUSING THE VEHICLE TO STALL UNEXPECTEDLY, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA/LEXUS MAILED AN INTERIM OWNER NOTIFICATION ON JULY 19, 2011 TO ADVISE OWNERS OF THIS RECALL AND THE FACT THAT THEY WILL RECEIVE A FUTURE NOTICE WHEN PARTS BECOME AVAILABLE TO COMPLETE REPAIRS. TOYOTA DEALERS WILL INSPECT THE HYBRID INVERTER PRODUCTION NUMBER TO DETERMINE WHETHER THE INVERTER CONTAINS SUSPECT TRANSISTORS AND REPLACE THE MODULE FREE OF CHARGE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
11V112000 · Vehicle Speed Control:accelerator Pedal
Feb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
Consequence & remedy
Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
06V253000 · Vehicle Speed Control:accelerator Pedal
Jul 13, 2006
ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.
Consequence & remedy
Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE11005 · Hybrid Inverter Failure - Vehicle Stall
Opened Feb 15, 2011 · Closed Jul 20, 2011
Status: closed (inferred from source dates) · Hybrid Propulsion System: Inverter
In a June 29, 2011 letter to NHTSA, Toyota submitted a Defect Information Report regarding a safety recall of certain Toyota Highlander Hybrid and Lexus RX400h vehicles to address a defect condition with the hybrid inverter assembly (NHTSA Recall No. 11V-342).Toyota's letter identified a defect related to inadequately soldered transistors on the Intelligent Power Module (IPM) of some of the subject vehicles that could result in sudden loss of power while driving.Toyota's remedy procedure instructs dealers to inspect the hybrid inverter production number to determine if the inverter contains suspect transistors.If so, the dealer will replace the IPM.The recall covers approximately 45,528 model year (MY) 2006 and 2007 Toyota Highlander Hybrid vehicles manufactured from February 16, 2005 through August 29, 2006 and approximately 36,745 MY 2006 and 2007 Lexus RX400h vehicles manufactured from February 23, 2005 through August 30, 2006.This Preliminary Evaluation is closed.
RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.