1997 Mercury Sable

DURING RAINY WEATHER, THE RIGHT FRONT TIRE SPLASHES WATER INTO THE ENGINE FAN BELT ASSEMBLY CAUSING THE FAN BELT TO SLIP AND SQUEAL. THE POWER STEERING PUMP FAILS TO TURN RESULTING IN HARD STEERING AND LOSS OF VEHICLE CONTROL, THE GENERATOR FAILS TO TURN RESULTING IN BATTERY LIGHT ILLUMINATION. THE RIGHT FRONT WHEELWELL BAFFLE ASSEMBLY INSTALLED BY THE MFG DOES NOT ADEQUATELY SHIELD THE FAN BELT ASSEMBLY FROM RAIN WATER INTRUSION. A TEMPORARY, THOUGHT INADEQUATE FIX, IS TO APPLY "BELT DRESSING" TO THE FAN BELT. REF COMPLAINT #551260. *AK

THE MOST RECENT PROBLEMS ARE ELECTRICAL IN NATURE. FIRST, ALL OF THE PASSENGER POWER WINDOWS HAVE FAILED. THEY CAN ONLY BE CONTROLLED BY THE DRIVER SIDE PANEL. SECOND, EVEN THOUGH ALL OF THE DOORS ARE SECURELY CLOSED, THE INTERIOR DOME LIGHT WILL REMAIN ON BETWEEN 20 SECONDS AND SEVERAL HOURS. THERE WERE OCCASIONS WHEN THE LIGHT WOULD COME ON BY ITSELF WHILE I WAS DRIVING DOWN THE HIGHWAY TO WORK. AN AUDIBLE CLICKING NOISE COULD BE HEARD FROM UNDER THE DASH. THE CLICK IS SIMILAR TO THE SOUND MADE WHEN MANUALLY OPERATING THE SWITCH. THIRD, THIS STARTED ON SUNDAY, 01/19/03, THE HEADLIGHTS WILL TURN ON AND OFF BY THEMSELVES WHILE THE VEHICLE IS OFF AND THE HEADLIGHT SWITCH IS OFF. ADDITIONALLY, WITH THE CAR RUNNING AND THE DAYTIME LIGHTS ONLY, THE HIGHBEAM INDICATOR CAME ON. WHEN I TURNED THE HEADLIGHTS ON, THE INDICATOR WENT OFF. WHEN I TURNED THE HEADLIGHTS OFF, THE HIGHBEAM INDICATOR CAME BACK ON. THE HIGHBEAM INDICATOR EVENTUALLY TURNED OFF ON ITS OWN WITHIN 5 OR 10 MINUTES. PREVIOUS PROBLEMS HAVE INCLUDED FRONT END SUSPENSION RELATED FAILURES AND AN OIL PAN THAT SPRUNG A LEAK IN DECEMBER 2001 AT AROUND 78K MILES. THE OIL PAN SPRUNG ANOTHER LEAK IN DECEMBER 2002. THE SERVICE DEALER ATTRIBUTED THE LEAK TO THE SAME PROBLEM AND ANOTHER FAILURE WITH THE OIL PRESSURE SWITCH. I AGREED TO THE OIL PRESSURE SWITCH REPAIR AND TOLD THEM THAT IF THE OIL PAN GASKET FAILED A 2ND TIME (ORIGINAL CAUSE OF LEAK IN 2001), THAT IT WAS DUE TO POOR REPAIR WORK. THEY TIGHTENED THE BOLTS TO THE OIL PAN. THE WINTER WEATHER HAS HAMPERED MY EFFORTS TO CHECK FOR THE LEAK. ALTHOUGH I NO LONGER SMELL BURNING OIL.

THE FIRE IN MY 1997 MERCURY SABLE STATION WAGON STARTED WHILE SITTING IN MY DRIVEWAY. IT HAD BEEN PARKED FOR ABOUT 11HOURS BEFORE THE FIRE STARTED ABOUT 1:30 AM . THE RIGHT REAR SECTION SHOWED THE MOST DAMAGE BUT THE ENTIRE INTERIOR WAS DESTROYED. THE GAS TANK WAS FULL BUT DID NOT EXPLODE. THE CAUSE OF THE FIRE IS UNKNOWN. THE INSURANCE COMPANY DECLARED THE CAR A TOTAL LOSS.*AK

CONSUMER STATES WHILE TRAVELING AT 50 TO 55 MPH VEHICLE SUDDENLY DIED. NO POWER BRAKES OR POWER STEERING. TOOK TO A MECHANIC STATED WIRES IN THE GAS TANK SHORTED OUT AND BLEW A BIG FUSE AND CAUSED VEHICLE TO SHUT OFF. MECHANIC STATED IF TANK HAD NOT BEEN FULL OF GAS THIS COULD HAVE IGNITED A FIRE. PLEASE PROVIDE ANY FURTHER INFORMATION.*JB

STARTED CAR, PROCEEDED TO LEAVE PARKING LOT AND SABLE STALLED. UNABLE TO RESTART. HAD VEHICLE TOWED TO DEALERSHIP WHERE VEHICLE WAS PURCHASED. FIRST ATTEMPT AT REPAIR REPLACED FUSE TO FUEL PUMP. LEFT DEALERSHIP AND VEHICLE STALLED AGAIN, 3 MILES AWAY FROM DEALERSHIP. VEHICLE TOWED BACK TO SAME DEALERSHIP. INVOICE 177076 READS "PREVIOUS REPAIR AS STATED ON RO-FUSE BLOWN. FOUND UND FAULTY SENDER AND PUMP TO FUEL TANK. PERFORMED MED EXTENSIVE TESTS TO REVEAL PROBLEM. REMOVED FUEL TANK FROM VEHICLE AND TESTED SENDER UNIT AND PUMP ASSEMBLY. FOUND CHAFFED WIRES INSIDE FUEL CELL WHICH COULD HAVE CAUSED A FIRE. REPAIR PARTS AND REASSEMBLED TANK TO VEHICLE. RETESTED AND PARTS SEEM TO BE WORKING AS DESIGNED."