NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
23 reportsClear category filterMileage unknown · Nov 12, 2015
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 20 MPH, THE VEHICLE LOST POWER AND RESTARTED AFTER NUMEROUS ATTEMPTS. THE CONTACT STATED THAT THE FUEL GAUGE WAS NOT REGISTERING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V0…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 20 MPH, THE VEHICLE LOST POWER AND RESTARTED AFTER NUMEROUS ATTEMPTS. THE CONTACT STATED THAT THE FUEL GAUGE WAS NOT REGISTERING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V074000 (FUEL SYSTEM). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 02/05/16*LJ
NHTSA ODI #10789907
105,000 miles · Aug 25, 2014
Fuel System, Gasoline
I WAS RIDING DOWN I25 WHEN MY TRUCK ENGINE UNEXPECTEDLY QUIT. AT 75 MPH IT WAS ALL I COULD DO TO CHANGE LANES AND PULL OVER TO THE MEDIAN WITHOUT CAUSING AN ACCIDENT. THE FUEL GAUGE SHOWED THAT I STILL HAD 1/4 TANK OF GAS. I TRIED REPEATEDLY TO START THE TRUCK WITHOUT SUCCESS. AFTER SCRATCHING MY HEAD FOR A WHILE I CALLED MY SON…
Read full complaint
I WAS RIDING DOWN I25 WHEN MY TRUCK ENGINE UNEXPECTEDLY QUIT. AT 75 MPH IT WAS ALL I COULD DO TO CHANGE LANES AND PULL OVER TO THE MEDIAN WITHOUT CAUSING AN ACCIDENT. THE FUEL GAUGE SHOWED THAT I STILL HAD 1/4 TANK OF GAS. I TRIED REPEATEDLY TO START THE TRUCK WITHOUT SUCCESS. AFTER SCRATCHING MY HEAD FOR A WHILE I CALLED MY SON TO BRING ME SOME GAS. AFTER ADDING GAS THE TRUCK STARTED UP AFTER A FEW TURNS OF THE IGNITION. NOT KNOWING WHAT THE HECK HAD HAPPENED I CONTINUED DRIVING THE TRUCK. UNFORTUNATELY I RAN OUT OF GAS AGAIN SOME WEEK LATER, THIS TIME IN A NEIGHBORHOOD WHERE THE SPEED ISSUE WAS NOT QUITE AS SEVERE. SINCE THAT TIME I'VE IGNORED MY FUEL GAUGE AND DETERMINED WHEN TO REFUEL BY MILEAGE. THIS IS REALLY AGGRAVATING BECAUSE THERE IS A RECALL ON TITAN FUEL SENDERS FOR MODEL YEAR 2005. HOWEVER NISSAN IS TELLING ME THAT MY VIN IS NOT COVERED BY THE RECALL. *TR
NHTSA ODI #10628251
Mileage unknown · Jul 31, 2014
Fuel System, Gasoline
WHILE DRIVING ON FREEWAY TRUCK SHUT OFF. GAS TANK READ QUARTER OF A TANK BUT ENGINE SHUT OFF-CAR WAS OUT OF GAS. *TR
NHTSA ODI #10617860
68,000 miles · Jun 20, 2014
Fuel System, GasolineFuel System, Other
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE FUEL GAUGE MALFUNCTIONED AND INACCURATELY DISPLAYED THAT FUEL WAS IN THE VEHICLE WHEN IT WAS EMPTY. THE FAILURE CAUSED THE VEHICLE TO SHUT OFF BECAUSE THERE WAS NO FUEL IN THE FUEL TANK. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING. THE CONTAC…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE FUEL GAUGE MALFUNCTIONED AND INACCURATELY DISPLAYED THAT FUEL WAS IN THE VEHICLE WHEN IT WAS EMPTY. THE FAILURE CAUSED THE VEHICLE TO SHUT OFF BECAUSE THERE WAS NO FUEL IN THE FUEL TANK. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 10V074000 (FUEL SYSTEM, OTHER ); HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 68,000. ..UPDATED 10/07/14 *BF
NHTSA ODI #10604852
52,500 miles · Jul 16, 2013
Fuel System, GasolineFuel System, Other
1ST INCIDENT OCCURRED DURING RUSH HOUR TRAFFIC. I WAS DRIVING AROUND 25MPH WHEN MY TITAN STARTED TO STALL AND THEN CAME TO A COMPLETE STOP, WAS JUST ABOUT REAR-END BY DELIVERY TRUCK. I WAS STUCK ON THE STREET IN THE MIDDLE OF TRAFFIC FOR 2 HOURS BEFORE A TOW TRUCK WAS ABLE TO COME TOW TRUCK. I HAD MECHANIC LOOK IT OVER AND IT …
Read full complaint
1ST INCIDENT OCCURRED DURING RUSH HOUR TRAFFIC. I WAS DRIVING AROUND 25MPH WHEN MY TITAN STARTED TO STALL AND THEN CAME TO A COMPLETE STOP, WAS JUST ABOUT REAR-END BY DELIVERY TRUCK. I WAS STUCK ON THE STREET IN THE MIDDLE OF TRAFFIC FOR 2 HOURS BEFORE A TOW TRUCK WAS ABLE TO COME TOW TRUCK. I HAD MECHANIC LOOK IT OVER AND IT CAME OUT THAT I HAD RUN OUT OF GAS, MECHANIC LOOKED AT FUEL GAUGE AND IT WAS READING OF TANK BUT WOULD NOT START. ONCE COUPLE GALLONS WERE ADDED TRUCK STARTED RIGHT UP. MECHANIC STATED THAT FUEL GAUGE IS READING WRONG, MECHANIC LOOKED UP TO SEE IF THERE WAS ANY RECALLS. THERE WAS A RECALL FOR THE 2005 NISSAN TITAN FOR THE FUEL SYSTEM NOT READING CORRECTLY. BUT DEALER STATED THAT MY VIN NUMBER DIDN'T FALL INTO THAT RECALL. MECHANIC STATED IT WOULD BE OVER $900 TO FIX. SO I HAD TO TELL THE MECHANIC NOT TO FIX IT. OVER THE YEARS, I HAVE RUN OUT OF GAS ABOUT 3 MORE TIMES DUE TO THE FUEL GAUGE NOT READING CORRECTLY. LAST TIME I RAN OUT OF GAS MY INFANT SON WAS IN TRUCK AND WAS JUST ABOUT SIDE SWIPED FROM ANOTHER VEHICLE AT AN INTERSECTION. I NEED TO DO WHAT NEEDS TO BE DONE TO GET MY NISSAN TITAN ADDED TO THIS RECALL, I CANNOT AFFORD TO PAY THIS TO BE FIXED. RECALL ID #68299 ? FUEL SYSTEM, OTHER: STORAGE:FUEL GAUGE SYSTEM. *TR
NHTSA ODI #10525238
Mileage unknown · May 9, 2013
Fuel System, GasolineVisibility
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHEN DRIVING VARIOUS SPEEDS, THE FUEL GAUGE READING WOULD FLUCTUATE EVEN THOUGH THE FUEL TANK WAS EMPTY. THE FAILURE RECURRED DESPITE THE ACTUAL FUEL LEVEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THERE WAS A VOLUNTARY RECALL ISSUED BY THE MAN…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHEN DRIVING VARIOUS SPEEDS, THE FUEL GAUGE READING WOULD FLUCTUATE EVEN THOUGH THE FUEL TANK WAS EMPTY. THE FAILURE RECURRED DESPITE THE ACTUAL FUEL LEVEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THERE WAS A VOLUNTARY RECALL ISSUED BY THE MANUFACTURER THAT WAS RELATED TO THE SAME DEFECT. THE CONTACT'S VIN WAS NOT INCLUDED AND THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE AIR CONDITIONING UNIT AND HEATER WOULD NOT CIRCULATE AIR PROPERLY THROUGH THE VENTS WHEN ACTIVATED. THERE WAS ALSO AN ABNORMAL CLICKING NOISE HEARD FROM THE VEHICLE. THERE WERE ALSO OCCASIONS WHEN THE AIR CONDITIONER WOULD INDEPENDENTLY SHUT OFF. THE AIR CONDITIONER BLOWER MOTOR WAS REPLACED BY THE DEALER HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS UNAVAILABLE.
NHTSA ODI #10511302
75,000 miles · May 3, 2013
Fuel System, GasolineFuel System, Other
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE FUEL GAUGE FAILED TO REGISTER WHEN THE FUEL TANK WAS FULL OR EMPTY. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE REPAIRS WERE MADE UNDER NHTSA CAMPAIGN NUMBER 10V074000 (FUEL SYSTEM, OTHER) HOWEVER, THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS MADE AWARE …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE FUEL GAUGE FAILED TO REGISTER WHEN THE FUEL TANK WAS FULL OR EMPTY. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE REPAIRS WERE MADE UNDER NHTSA CAMPAIGN NUMBER 10V074000 (FUEL SYSTEM, OTHER) HOWEVER, THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS MADE AWARE OR THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000 AND THE CURRENT MILEAGE WAS 91,000. ...UPDATED 07/22/13 *BF
NHTSA ODI #10510547
91,000 miles · Aug 28, 2012
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED WHILE DRIVING 50 MPH THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSE THAT THE FUEL SENDER UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE W…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED WHILE DRIVING 50 MPH THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSE THAT THE FUEL SENDER UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 10V074000 (FUEL SYSTEM). THE FAILURE AND THE CURRENT MILEAGE WAS 91,000.....UPDATED 10/11/12 *BF UPDATED 10/16/12
NHTSA ODI #10472762
107,455 miles · Apr 25, 2012
Electrical SystemFuel System, GasolineSuspension
THIS VEHICLE HAS MORE COMMON FAILURES THAN ANY I HAVE SEEN. BOTH OF THE REAR LEAF SPRING SHACKLES ROTTED OUT. THE REAR AXLE SEALS ARE NOW LEAKING. IN 6 MONTHS I HAVE REPLACED 2 OXYGEN SENSORS AND NOW FOR THE 2ND TIME I AM REPLACING THE EVAP CANISTER CONTROL VALVE. NISSAN SEEMS TO IGNORE ALL OF THESE ISSUES AND HAS REDESIGNED MAN…
Read full complaint
THIS VEHICLE HAS MORE COMMON FAILURES THAN ANY I HAVE SEEN. BOTH OF THE REAR LEAF SPRING SHACKLES ROTTED OUT. THE REAR AXLE SEALS ARE NOW LEAKING. IN 6 MONTHS I HAVE REPLACED 2 OXYGEN SENSORS AND NOW FOR THE 2ND TIME I AM REPLACING THE EVAP CANISTER CONTROL VALVE. NISSAN SEEMS TO IGNORE ALL OF THESE ISSUES AND HAS REDESIGNED MANY OF THESE PROBLEM AREAS IN NEWER MODELS HOWEVER DOES NOT OWN UP TO FIXING THE ISSUES ON VEHICLES THAT ARE ON THE ROAD. *TR
NHTSA ODI #10456492
93,000 miles · Mar 29, 2012
Fuel System, Gasoline
IN AUGUST OF 2010 WAS THE FIRST TIME I EXPERIENCED A PROBLEM. THE VEHICLE LOST POWER AND DIED WHILE DRIVING ON A MAIN STREET GOING APPROXIMATELY 45 MPH. LATER I DISCOVERED THAT THE VEHICLE WAS OUT OF GAS DESPITE THE FUEL GAUGE BEING AT 1/4 TANK. TODAY, AFTER NEARLY 1 1/2 OF KEEPING MY TRUCK ABOVE 1/4 TANK AND LOGGING MY MIL…
Read full complaint
IN AUGUST OF 2010 WAS THE FIRST TIME I EXPERIENCED A PROBLEM. THE VEHICLE LOST POWER AND DIED WHILE DRIVING ON A MAIN STREET GOING APPROXIMATELY 45 MPH. LATER I DISCOVERED THAT THE VEHICLE WAS OUT OF GAS DESPITE THE FUEL GAUGE BEING AT 1/4 TANK. TODAY, AFTER NEARLY 1 1/2 OF KEEPING MY TRUCK ABOVE 1/4 TANK AND LOGGING MY MILES, THE VEHICLE ENGINE POWER DIED ON ME AND FAILED TO START BECAUSE ONCE AGAIN IT WAS OUT OF FUEL...THIS TIME READING JUST UNDER 1/2 TANK. BOTH SITUATIONS ARE EXTREMELY UNSAFE AND CAUSED UNNECESSARY STRESS. I'VE CALLED THE DEALER AND THEY ARE AWARE OF PROBLEMS WITH THE FUEL SENDING UNIT ON THE NISSAN TITAN MODEL TRUCKS BUT CAN NOT DO ANYTHING WITHOUT THE OFFICIAL RECALL. IT IS WIDELY KNOWN THAT THERE IS A RECALL ON SOME OF THE NISSAN TITAN MODELS AND SHOULD BE EXTENDED THROUGHOUT ALL OF THE FAILING FUEL SYSTEMS BEFORE MYSELF OR SOMEONE IS FACED WITH EXTREME INJURY. *TR *JS
NHTSA ODI #10453510
Official recalls
4Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration