Power Train. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

16 crash reports15 fire reports12 injury reports

Fuel System, Other complaints

4 reports

Clear category filter

Mileage unknown · Jun 26, 2006

Electrical SystemEngine And Engine CoolingFuel System, Other

Read full complaint

DT*: THE CONTACT STATED SINCE THE VEHICLE WAS PURCHASED IN 2002 FROM AN INDEPENDENT DEALER, THE VEHICLE HAS BEEN HAVING ON GOING PROBLEMS WITH THE ELECTRICAL WIRING, ALTERNATOR, RADIATOR, THERMOSTAT, COOLING SYSTEM. DIAGNOSTIC TESTING IS NEEDED FOR GROSS POLLUTION. THE VEHICLE HAS FAILED UNDER FAIR WEATHER CONDITIONS THREE TIMES SINCE PURCHASE. EVENTS LEADING UP TO THE FAILURES OF THE FAN, RADIATOR AND TRANSMISSION OCCURRED WHEN VEHICLE STARTED TO RUN HOT, CAUSING TRANSMISSION TO BLOW OUT. SERVICE FOR THESE COMPONENTS WERE PERFORMED AT AN INDEPENDANT AUTO SHOP.

NHTSA ODI #10160769

Mileage unknown · Sep 14, 2004

Fuel System, Other

PURCHASED VEHICLE USED A YEAR AGO, AFTER 1 FUEL FILL UP SERVICE ENGINE LIGHT CAME ON AND SMELLED FUEL STRONGLY IN THE BACK. NOTICED RAW FUEL LEAKING ONTO THE LEFT REAR TIRE& WHEEL WELL. TOOK TO DEALER FOR TESTS, THEY FOUND LEAKS FROM LDP TO THE TANK AT A RUBBER ELBOW WITH A RAW FUEL LEAK AT THE CONNECTION BETWEEN THE FILLER NE…

Read full complaint

NHTSA ODI #10090966

Mileage unknown · Apr 4, 2001

Air BagsElectrical SystemFuel System, OtherCrashInjury

WHEN VAN WAS HIT BY ANOTHER VEHICLE, ON THE PASSENGER'S SIDE AT A HIGH RATE OF SPEED, THERE WAS NO DEPLOYMENT OF THE PASSENGER'S FRONT AIR BAG. ALSO, HORN DOES NOT WORK, REMOTE ENTRY ON DRIVER'S SIDE DOOR DOES NOT WORK, AIR BAG WARNING LIGHT STAYS ON, FUEL GAUGES DOES NOT WORK, A/C HEATER BLINK ON AND OFF,INSIDE DOME LIGHT BLINK…

Read full complaint

NHTSA ODI #9002210

Mileage unknown · Feb 1, 1999

Engine And Engine CoolingFuel System, Other

FUEL SENSOR FAILED. YH

NHTSA ODI #607212

Official recalls

02V293000 · Air Bags:frontal

Nov 7, 2002

ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.

Consequence & remedy

Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.

Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

00V268000 · Fuel System, Gasoline:fuel Injection System

Sep 13, 2000

VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.

Consequence & remedy

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

98V185000 · Child Seat

Aug 6, 1998

VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.

Consequence & remedy

Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.

Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.

97V200000 · Tires:bead

Nov 13, 1997

VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.

Consequence & remedy

Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA01007 · Air Bag Clockspring

Opened Feb 21, 2001 · Closed Nov 22, 2002

Status: closed (inferred from source dates) · Electrical System

There is no summary currently available

RQ00008 · Dc Minivan Fuel Injector Rail Leak

Opened Mar 9, 2000 · Closed Mar 18, 2002

Status: closed (inferred from source dates) · Vehicle Speed Control:linkages

There is no summary currently available

EA99013 · Post Collision Fuel System

Opened Jun 11, 1999 · Closed Aug 10, 2001

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

No summary supplied.

PE99010 · POST-COLLISION Fuel System Integrity

Opened Feb 3, 1999 · Closed Jun 11, 1999

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

There is no summary currently available

EA97003 · Integrated Child Seat Belt Lockup

Opened Jan 31, 1997 · Closed Aug 19, 1998

Status: closed (inferred from source dates) · Child Seat

THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.

Additional source detail variants (2)

Child Seat

SQ96016 · Integrated Child Seat Belt Lockup

Opened Sep 18, 1996 · Closed Feb 4, 1997

Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat

ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.