NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
145 reportsClear category filter203,202 miles · Jul 5, 2022
Electronic Stability Control (esc)Exterior LightingService Brakes, Hydraulic
The contact owns a 2007 Toyota Prius. The contact stated that while driving the speed was unknown due to the instrument cluster being inoperable. On another occasion while driving approximately 45 MPH, the brake pedal was depressed but failed to operate properly; however, on that occasion the instrument cluster was operating as …
Read full complaint
The contact owns a 2007 Toyota Prius. The contact stated that while driving the speed was unknown due to the instrument cluster being inoperable. On another occasion while driving approximately 45 MPH, the brake pedal was depressed but failed to operate properly; however, on that occasion the instrument cluster was operating as designed. The vehicle stability control, ABS, and brake light warning lights were illuminated. The vehicle was taken to an independent mechanic and diagnosed with an actuator and brake booster failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 203,202.
NHTSA ODI #11472401
117,000 miles · Sep 3, 2013
Service Brakes, HydraulicCrash
I HAVE A 2007 PRIUS. THE CAR WAS INVOLVED IN AN ACCIDENT ON AUGUST 30, 2013 BECAUSE "NO BRAKE". IT WAS IN A STOP AND GO SITUATION TRAVELING AT ABOUT 20 MILES PER HOUR. THE CAR IN FRONT STOPPED, I SLAMMED ON THE BRAKE AND TOTAL BRAKE FAILURE. MY 16 YEARS OLD SON SITTING IN THE CAR OBSERVED THE "NO BRAKE" SCENARIO. THERE WAS A 2…
Read full complaint
I HAVE A 2007 PRIUS. THE CAR WAS INVOLVED IN AN ACCIDENT ON AUGUST 30, 2013 BECAUSE "NO BRAKE". IT WAS IN A STOP AND GO SITUATION TRAVELING AT ABOUT 20 MILES PER HOUR. THE CAR IN FRONT STOPPED, I SLAMMED ON THE BRAKE AND TOTAL BRAKE FAILURE. MY 16 YEARS OLD SON SITTING IN THE CAR OBSERVED THE "NO BRAKE" SCENARIO. THERE WAS A 25 POUND OF RICE IN THE TRUCK DID NOT EVEN MOVE. NO SKIP MARK... NOTHING. TOOK MY CAR TO LONGO TOYOTA AND FOUND NOTHING WITH THE BRAKE SYSTEM, OTHER THAN THE FRONT PAD WAS THIN, TIRES WERE MARGINAL ETC. NONE OF THE FINDINGS EXPLAINED THE NO BRAKE SCENARIO. FOR SOME REASON I CANNOT MAKE THIS NO BRAKE TO APPEAR AGAIN. I WANT PEOPLE TO AWARE OF THIS AND GATHER INFORMATION. IT APPEARS TO ME THE PRIUS CANNOT RESPONSE TO A QUICK STOP AT SLOW SPEED. SOMEHOW, THE CAR TAKES MORE THAN A SECOND FOR THE BRAKING TO KICK IN - THE REACTION DOES NOT APPEAR TO BE INSTANTANEOUS. AND IF YOU ARE TOO CLOSE, THAT EXTRA ONE SECOND WAIT WILL CAUSE A COLLISION.
NHTSA ODI #10541724
500 miles · Apr 26, 2011
Service Brakes, Hydraulic
WHEN THE BRAKES ARE APPLIED IN DECELERATION AND THE VEHICLE HITS A BUMP OR POTHOLE, THE BRAKES RELEASE FOR A SECOND, THEN GRAB AGAIN, EVEN THOUGH FOOT PRESSURE HAS NOT CHANGED.
NHTSA ODI #10397890
53,950 miles · Feb 9, 2011
Service Brakes, Hydraulic
I WAS DRIVING IN THE RIGHT LANE OF A 4-LANE BOULEVARD. THE VEHICLE AHEAD IN THE LANE TO MY LEFT SLOWED FOR A CAR IN FRONT WAITING TO MAKE A LEFT TURN, THEN SUDDENLY VEERED INTO MY LANE. I HIT THE BRAKES AS HARD AS I COULD, BUT FOR THE FIRST 2-3 SECONDS, MY CAR DIDN'T SLOW DOWN. IT ALSO DIDN'T MAKE ANY SOUNDS I WOULD HAVE EXPE…
Read full complaint
I WAS DRIVING IN THE RIGHT LANE OF A 4-LANE BOULEVARD. THE VEHICLE AHEAD IN THE LANE TO MY LEFT SLOWED FOR A CAR IN FRONT WAITING TO MAKE A LEFT TURN, THEN SUDDENLY VEERED INTO MY LANE. I HIT THE BRAKES AS HARD AS I COULD, BUT FOR THE FIRST 2-3 SECONDS, MY CAR DIDN'T SLOW DOWN. IT ALSO DIDN'T MAKE ANY SOUNDS I WOULD HAVE EXPECTED FROM URGENT BRAKING - NO SCREECHING TIRES, ETC. I CONTINUED TO PUSH THE BRAKE PEDAL HARD. AFTER 2-3 SECONDS, THE BRAKES FINALLY GRABBED AND MY CAR PULLED TO THE RIGHT. I CONSIDERED MYSELF LUCKY THAT I HAD ENOUGH ROOM TO AVOID HITTING THE VEHICLE IN FRONT OF ME.
NHTSA ODI #10382214
25,432 miles · Dec 27, 2010
Service Brakes, HydraulicCrash
TL*THE CONTACT OWNS A 2007 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE FAILED TO STOP AS THE CONTACT APPROACHED A TRAFFIC LIGHT. THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE POLICE WERE CALLED TO THE SCENE. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS DECLARED A TOTAL LOSS. THE FAILURE MILEAGE…
Read full complaint
TL*THE CONTACT OWNS A 2007 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE FAILED TO STOP AS THE CONTACT APPROACHED A TRAFFIC LIGHT. THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE POLICE WERE CALLED TO THE SCENE. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS DECLARED A TOTAL LOSS. THE FAILURE MILEAGE WAS 25,432. UPDATED 02/17/11*LJ UPDATED 05/02/11
NHTSA ODI #10372500
32,500 miles · Dec 4, 2010
Electronic Stability Control (esc)Service Brakes, Hydraulic
DASHBOARD RED LIGHTS WHEN VEHICLE STARTS WITH: BRAKE FAILURE , ABS WARNING AND STABILITY WARNING. FIRST TIME IT WAS IMMEDIATELY TAKEN TO DEALER WHO COULD FIND NO PROBLEM AND RESET CODES. FOUR DAYS LATER SAME WARNING LIGHTS CAME ON AND WAS TAKEN TO DEALER AGAIN. WERE TOLD HYDRAULIC BRAKE SYSTEM WAS OK BUT BRAKE ACTUATOR NEEDED RE…
Read full complaint
DASHBOARD RED LIGHTS WHEN VEHICLE STARTS WITH: BRAKE FAILURE , ABS WARNING AND STABILITY WARNING. FIRST TIME IT WAS IMMEDIATELY TAKEN TO DEALER WHO COULD FIND NO PROBLEM AND RESET CODES. FOUR DAYS LATER SAME WARNING LIGHTS CAME ON AND WAS TAKEN TO DEALER AGAIN. WERE TOLD HYDRAULIC BRAKE SYSTEM WAS OK BUT BRAKE ACTUATOR NEEDED REPLACEMENT AT $2600. COULD BE DRIVEN BUT WITHOUT ABS AND STABILITY CAPABILITY. HAVE NOT CORRECTED THIS DUE TO HIGH PRICE. SHOPPING AROUND AT SALVAGE YARDS. *TR
NHTSA ODI #10369181
43,000 miles · Aug 18, 2010
Air BagsService Brakes, HydraulicSteeringCrashInjury
TL* THE CONTACT OWNS A 2007 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE BEGAN ABNORMALLY SLIDING TOWARD THE LEFT. THE CONTACT ATTEMPTED TO STEER THE VEHICLE TOWARD THE RIGHT BUT THE VEHICLE WOULD NOT CHANGE DIRECTION. THE CONTACT THEN ATTEMPTED TO BRAKE BUT THE VEHICLE WOULD NOT STOP. THE CONTACT WAS UNABLE TO…
Read full complaint
TL* THE CONTACT OWNS A 2007 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE BEGAN ABNORMALLY SLIDING TOWARD THE LEFT. THE CONTACT ATTEMPTED TO STEER THE VEHICLE TOWARD THE RIGHT BUT THE VEHICLE WOULD NOT CHANGE DIRECTION. THE CONTACT THEN ATTEMPTED TO BRAKE BUT THE VEHICLE WOULD NOT STOP. THE CONTACT WAS UNABLE TO MAINTAIN CONTROL OF THE VEHICLE WHICH RESULTED IN A SINGLE VEHICLE ROLLOVER CRASH. THE AIR BAGS DID NOT DEPLOY. THE POLICE APPEARED ON THE SCENE AND SPECULATED THAT THE FRONT PASSENGER SIDE TIRE BLEW PRIOR TO THE CRASH. A POLICE REPORT WAS AVAILABLE. AN AMBULANCE ALSO APPEARED ON THE SCENE AS THE CONTACT SUSTAINED MINOR INJURIES. THE VEHICLE WAS DESTROYED AND TOWED TO AN INSURANCE COMPANY LOT. THE VEHICLE WAS NOT EXAMINED FOR THE CAUSE OF FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 43,000.
NHTSA ODI #10350326
200 miles · Jul 30, 2010
Service Brakes, Hydraulic
WHEN BRAKING & GOING OVER A BUMP IN MY 2007 PRIUS, IT FEELS LIKE THE BRAKES DISENGAGE FOR A SECOND & CAR GOES FASTER. IF THERE WAS A CAR IN FRONT OF ME I WOULD HIT IT & IF I HAD TO STOP SUDDENLY THEN I'M NOT CONFIDENT I COULD. IT IS DISTURBING. FEELS LIKE THE BRAKES ARE FAILING. *TR
NHTSA ODI #10346399
18,000 miles · Jul 14, 2010
Electrical SystemService Brakes, HydraulicVehicle Speed ControlCrashInjury
TL* THE CONTACT OWNS A 2007 TOYOTA PRIUS. THE CONTACT ATTEMPTED TO PARK THE VEHICLE INTO THE RESIDENCE GARAGE, DRIVING AT APPROXIMATELY 2 MPH. SUDDENLY, THERE WAS AN UNINTENDED ACCELERATION. THE BRAKES WERE ENGAGED AND THE VEHICLE CONTINUED TO ACCELERATE CAUSING THE VEHICLE TO CRASH INTO A CLOSET IN THE GARAGE. THE CONTACT SUF…
Read full complaint
TL* THE CONTACT OWNS A 2007 TOYOTA PRIUS. THE CONTACT ATTEMPTED TO PARK THE VEHICLE INTO THE RESIDENCE GARAGE, DRIVING AT APPROXIMATELY 2 MPH. SUDDENLY, THERE WAS AN UNINTENDED ACCELERATION. THE BRAKES WERE ENGAGED AND THE VEHICLE CONTINUED TO ACCELERATE CAUSING THE VEHICLE TO CRASH INTO A CLOSET IN THE GARAGE. THE CONTACT SUFFERED INJURY TO THE NECK AREA. THE VEHICLE FRONT BUMPER SUSTAINED DAMAGES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE IDENTICAL FAILURES OCCURRED ON TWO SEPARATE OCCASIONS WITH NO INJURIES. IN ADDITION, THE CONTACT EXPERIENCED MALFUNCTIONS WITH THE AUTOMATIC IGNITION SWITCH, WINDSHIELD WIPERS, AND THE FRONT DRIVER AND PASSENGER SIDE AUTOMATIC WINDOW MECHANISM. THE FAILURES OCCURRED SPORADICALLY. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 18,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10343225
Mileage unknown · Jul 12, 2010
Service Brakes, HydraulicVehicle Speed Control
2007 TOYOTA PRIUS. CONSUMER STATES ACCELERATOR AND BRAKE PROBLEMS *TGW THE CONSUMER STATED WHILE DRIVING THE VEHICLE, AT TIMES IT WOULD FEEL LIKE EITHER THE BRAKES MOMENTARILY DISENGAGED AND/OR THE VEHICLE WOULD SUDDENLY SURGED SLIGHTLY FOR A SECOND. *JB
NHTSA ODI #10342219
Official recalls
4Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
PE09019 · Headlight Failure
Opened Apr 17, 2009 · Closed Aug 27, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights
ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT BOTH HEADLIGHTS WOULD GO OUT, OR EXTINGUISH WHILE DRIVING.THE SUBJECT VEHICLES ARE EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) HEADLAMPS THAT OPERATE ON INDEPENDENT LAMPS AND ECU'S (ELECTRONIC CONTROL UNITS) FOR EACH HEADLIGHT, MEANING THAT EACH HEADLIGHT RUNS INDEPENDENTLY OF THE OTHER, AND A FAILURE IN ONE LAMP OR ECU DOES NOT NECESSARILY RESULT IN A FAILURE OF THE OTHER.DURING THE INVESTIGATION, A RANDOM SAMPLE OF FORTY CONSUMERS WAS CONTACTED BY ODI IN A TELEPHONE SURVEY TO VERIFY THEIR EXPERIENCES.THE CONSUMERS STATED IN COMPLAINTS TO TOYOTA THAT BOTH HEADLIGHTS FAILED AT THE SAME TIME.ODI DISCOVERED THROUGH TALKING WITH THESE COMPLAINANTS THAT IN FACT ONE HEADLIGHT WOULD BEGIN TO FLICKER AND THEN CUT OFF.THE OTHER HEADLIGHT WOULD STILL BE OPERATIONAL.IN A FEW CASES WHERE NO ACTION WAS TAKEN, SOME COMPLAINANTS STATED THAT AFTER A FEW MONTHS BOTH HEADLAMPS WOULD BEGIN TO FAIL RESULTING IN NO HEADLIGHTS; HOWEVER NONE REPORTED THAT BOTH LAMPS FAILED SIMULTANEOUSLY.COMPLAINANTS ALSO STATED THAT THEY COULD TOGGLE THE HEADLAMP SWITCH ON AND OFF TO TEMPORARILY RESTORE LIGHTING WHEN THIS CONDITION OCCURRED, EVEN IN CASES WERE BOTH HEADLAMPS WERE EXTINGUISHED.THE RESULTS OF THIS SURVEY ARE LARGELY CONSISTENT WITH ODI'S ASSESSMENT OF THE REPORTS AND WARRANTY DATA.TOYOTA SUBMITTED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER THAT, GENERALLY SPEAKING, ONLY ONE LAMP FAILED AT A TIME, AND THAT TOGGLING THE SWITCH RESTORED THE LAMP.TOYOTA REQUESTED A MEETING WITH ODI AND ON AUGUST 6, 2009, PRESENTED THEIR ASSESSMENT OF HEADLAMP FAILURE.TOYOTA CONFIRMED THAT A HEADLAMP COULD EXTINGUISH WHILE DRIVING DUE TO A BULB FAILURE, AND THAT IT COULD BE TEMPORARILY RESTORED BY TURNING THE HEADLIGHT SWITCH ON AND OFF, AND THAT SIMULTANEOUS FAILURE OF BOTH HEADLAMPS WAS RARE AND UNLIKELY.TOYOTA ALSO BRIEFLY DISCUSSED THEIR INTENTION TO CONDUCT A CUSTOMER SERVICE CAMPAIGN TO ADDRESS CONSUMER DISSATISFACTION WITH HID BULB FAILURES.SINCE THERE IS STILL ONE HEADLIGHT OPERATING WHEN THE OTHER ONE CUTS OFF, THERE IS STILL LIGHTING AVAILABLE TO GET THE VEHICLE TO A REPAIR FACILITY.THUS, A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:headlights
ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT BOTH HEADLIGHTS WOULD GO OUT, OR EXTINGUISH WHILE DRIVING.THE SUBJECT VEHICLES ARE EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) HEADLAMPS THAT OPERATE ON INDEPENDENT LAMPS AND ECU'S (ELECTRONIC CONTROL UNITS) FOR EACH HEADLIGHT, MEANING THAT EACH HEADLIGHT RUNS INDEPENDENTLY OF THE OTHER, AND A FAILURE IN ONE LAMP OR ECU DOES NOT NECESSARILY RESULT IN A FAILURE OF THE OTHER.DURING THE INVESTIGATION, A RANDOM SAMPLE OF FORTY CONSUMERS WAS CONTACTED BY ODI IN A TELEPHONE SURVEY TO VERIFY THEIR EXPERIENCES.THE CONSUMERS STATED IN COMPLAINTS TO TOYOTA THAT BOTH HEADLIGHTS FAILED AT THE SAME TIME.ODI DISCOVERED THROUGH TALKING WITH THESE COMPLAINANTS THAT IN FACT ONE HEADLIGHT WOULD BEGIN TO FLICKER AND THEN CUT OFF.THE OTHER HEADLIGHT WOULD STILL BE OPERATIONAL.IN A FEW CASES WHERE NO ACTION WAS TAKEN, SOME COMPLAINANTS STATED THAT AFTER A FEW MONTHS BOTH HEADLAMPS WOULD BEGIN TO FAIL RESULTING IN NO HEADLIGHTS; HOWEVER NONE REPORTED THAT BOTH LAMPS FAILED SIMULTANEOUSLY.COMPLAINANTS ALSO STATED THAT THEY COULD TOGGLE THE HEADLAMP SWITCH ON AND OFF TO TEMPORARILY RESTORE LIGHTING WHEN THIS CONDITION OCCURRED, EVEN IN CASES WERE BOTH HEADLAMPS WERE EXTINGUISHED.THE RESULTS OF THIS SURVEY ARE LARGELY CONSISTENT WITH ODI'S ASSESSMENT OF THE REPORTS AND WARRANTY DATA.TOYOTA SUBMITTED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER THAT, GENERALLY SPEAKING, ONLY ONE LAMP FAILED AT A TIME, AND THAT TOGGLING THE SWITCH RESTORED THE LAMP.TOYOTA REQUESTED A MEETING WITH ODI AND ON AUGUST 6, 2009, PRESENTED THEIR ASSESSMENT OF HEADLAMP FAILURE.TOYOTA CONFIRMED THAT A HEADLAMP COULD EXTINGUISH WHILE DRIVING DUE TO A BULB FAILURE, AND THAT IT COULD BE TEMPORARILY RESTORED BY TURNING THE HEADLIGHT SWITCH ON AND OFF, AND THAT SIMULTANEOUS FAILURE OF BOTH HEADLAMPS WAS RARE AND UNLIKELY.TOYOTA ALSO BRIEFLY DISCUSSED THEIR INTENTION TO CONDUCT A CUSTOMER SERVICE CAMPAIGN TO ADDRESS CONSUMER DISSATISFACTION WITH HID BULB FAILURES.SINCE THERE IS STILL ONE HEADLIGHT OPERATING WHEN THE OTHER ONE CUTS OFF, THERE IS STILL LIGHTING AVAILABLE TO GET THE VEHICLE TO A REPAIR FACILITY.THUS, A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting
ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT BOTH HEADLIGHTS WOULD GO OUT, OR EXTINGUISH WHILE DRIVING.THE SUBJECT VEHICLES ARE EQUIPPED WITH HIGH INTENSITY DISCHARGE (HID) HEADLAMPS THAT OPERATE ON INDEPENDENT LAMPS AND ECU'S (ELECTRONIC CONTROL UNITS) FOR EACH HEADLIGHT, MEANING THAT EACH HEADLIGHT RUNS INDEPENDENTLY OF THE OTHER, AND A FAILURE IN ONE LAMP OR ECU DOES NOT NECESSARILY RESULT IN A FAILURE OF THE OTHER.DURING THE INVESTIGATION, A RANDOM SAMPLE OF FORTY CONSUMERS WAS CONTACTED BY ODI IN A TELEPHONE SURVEY TO VERIFY THEIR EXPERIENCES.THE CONSUMERS STATED IN COMPLAINTS TO TOYOTA THAT BOTH HEADLIGHTS FAILED AT THE SAME TIME.ODI DISCOVERED THROUGH TALKING WITH THESE COMPLAINANTS THAT IN FACT ONE HEADLIGHT WOULD BEGIN TO FLICKER AND THEN CUT OFF.THE OTHER HEADLIGHT WOULD STILL BE OPERATIONAL.IN A FEW CASES WHERE NO ACTION WAS TAKEN, SOME COMPLAINANTS STATED THAT AFTER A FEW MONTHS BOTH HEADLAMPS WOULD BEGIN TO FAIL RESULTING IN NO HEADLIGHTS; HOWEVER NONE REPORTED THAT BOTH LAMPS FAILED SIMULTANEOUSLY.COMPLAINANTS ALSO STATED THAT THEY COULD TOGGLE THE HEADLAMP SWITCH ON AND OFF TO TEMPORARILY RESTORE LIGHTING WHEN THIS CONDITION OCCURRED, EVEN IN CASES WERE BOTH HEADLAMPS WERE EXTINGUISHED.THE RESULTS OF THIS SURVEY ARE LARGELY CONSISTENT WITH ODI'S ASSESSMENT OF THE REPORTS AND WARRANTY DATA.TOYOTA SUBMITTED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER THAT, GENERALLY SPEAKING, ONLY ONE LAMP FAILED AT A TIME, AND THAT TOGGLING THE SWITCH RESTORED THE LAMP.TOYOTA REQUESTED A MEETING WITH ODI AND ON AUGUST 6, 2009, PRESENTED THEIR ASSESSMENT OF HEADLAMP FAILURE.TOYOTA CONFIRMED THAT A HEADLAMP COULD EXTINGUISH WHILE DRIVING DUE TO A BULB FAILURE, AND THAT IT COULD BE TEMPORARILY RESTORED BY TURNING THE HEADLIGHT SWITCH ON AND OFF, AND THAT SIMULTANEOUS FAILURE OF BOTH HEADLAMPS WAS RARE AND UNLIKELY.TOYOTA ALSO BRIEFLY DISCUSSED THEIR INTENTION TO CONDUCT A CUSTOMER SERVICE CAMPAIGN TO ADDRESS CONSUMER DISSATISFACTION WITH HID BULB FAILURES.SINCE THERE IS STILL ONE HEADLIGHT OPERATING WHEN THE OTHER ONE CUTS OFF, THERE IS STILL LIGHTING AVAILABLE TO GET THE VEHICLE TO A REPAIR FACILITY.THUS, A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration