The contact owns a 2014 Toyota Prius. The contact stated was unable to start the vehicle. Additionally, the hybrid system warning light was illuminated. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the inverter assembly to be replaced. The vehicle was not re…
Read full complaint
The contact owns a 2014 Toyota Prius. The contact stated was unable to start the vehicle. Additionally, the hybrid system warning light was illuminated. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the inverter assembly to be replaced. The vehicle was not repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 20V369000 (Hybrid Propulsion System). The manufacturer was informed of the failure and the contact was informed that the recall repair had been performed on August 20, 2020. The failure mileage was approximately 86,500.
NHTSA ODI #11525969
44,250 miles · Apr 29, 2021
Electrical SystemHybrid Propulsion System
TL* THE CONTACT OWNS A 2014 TOYOTA PRIUS. THE CONTACT STATED WHILE DRIVING 75 MPH, THE CONTACT RELEASED HER FOOT OFF OF THE BRAKE PEDAL AND DEPRESSED THE ACCELERATE PEDAL HOWEVER, THE VEHICLE FAILED TO RESPOND. AN UNKNOWN WARNING LIGHT ILLUMINATED AND WAS FLASHING ON THE INSTRUMENT PANEL. THE CONTACT COASTED THE VEHICLE TO THE S…
Read full complaint
TL* THE CONTACT OWNS A 2014 TOYOTA PRIUS. THE CONTACT STATED WHILE DRIVING 75 MPH, THE CONTACT RELEASED HER FOOT OFF OF THE BRAKE PEDAL AND DEPRESSED THE ACCELERATE PEDAL HOWEVER, THE VEHICLE FAILED TO RESPOND. AN UNKNOWN WARNING LIGHT ILLUMINATED AND WAS FLASHING ON THE INSTRUMENT PANEL. THE CONTACT COASTED THE VEHICLE TO THE SHOULDER OF THE ROADWAY AND STOPPED THE VEHICLE. THE VEHICLE WAS NOT TURNED OFF. AFTER WAITING FOR APPROXIMATELY 10 MINUTES, THE VEHICLE RESUMED NORMAL FUNCTIONALITY. THE VEHICLE WAS DRIVEN TO TOYOTA TOWN OF STOCKTON (2150 E HAMMER LN, STOCKTON, CA 95210, (209) 751-4077) TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE CONTACT MENTIONED THAT WHILE READING THE INFORMATION FROM THE DIAGNOSTIC TEST, SHE NOTICED THAT THE INVERTER HAD NOT BEEN DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V053000 (HYBRID PROPULSION SYSTEM, ELECTRICAL SYSTEM) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND CONFIRMED THAT THE VIN WAS NOT UNDER RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 44,250.
NHTSA ODI #11414427
112,971 miles · Sep 30, 2020
Hybrid Propulsion SystemService Brakes, Hydraulic
TL* THE CONTACT OWNS A 2014 TOYOTA PRIUS. THE CONTACT STATED WHILE DRIVING 35 MPH, THE VEHICLE LOSS MOTIVE POWER WITH THE CHECK ENGINE AND HYBRID BATTERY WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO LITHIA TOYOTA OF MEDFORD (1420 N RIVERSIDE AVE, MEDFORD, OR 97501) WHERE IT WAS DETERMINED THAT THE HYBRID BATTERY INTAKE F…
Read full complaint
TL* THE CONTACT OWNS A 2014 TOYOTA PRIUS. THE CONTACT STATED WHILE DRIVING 35 MPH, THE VEHICLE LOSS MOTIVE POWER WITH THE CHECK ENGINE AND HYBRID BATTERY WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO LITHIA TOYOTA OF MEDFORD (1420 N RIVERSIDE AVE, MEDFORD, OR 97501) WHERE IT WAS DETERMINED THAT THE HYBRID BATTERY INTAKE FAILED AND NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. TWO WEEKS LATER FAILURE AN ABNORMAL SOUND WAS HEARD COMING FROM THE BRAKES. THE VEHICLE THEN WAS TAKEN BACK TO THE SAME DEALER HOWEVER, A DIAGNOSTIC TEST WAS STILL PENDING. THE CONTACT REFERENCED NHTSA ACTION NUMBER: DP19004 (SERVICE BRAKES, HYDRAULIC) 18V684000 (HYBRID PROPULSION SYSTEM) AS POSSIBLE SOLUTIONS TO THE FAILURES HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 112,971.
NHTSA ODI #11362052
429 miles · Jun 18, 2014
Electrical SystemHybrid Propulsion System
I PURCHASED A 2014 TOYOTA PRIUS ON MAY 31, 2014. TODAY 6/18/14 I FOUND OUT THERE WAS A RECALL ON THIS MODEL VEHICLE. I CALLED TOYOTA AND I WAS INFORMED THE RECALL SERVICE HAD NOT BEEN PERFORMED. I CALLED A LOCAL DEALER (DIFFERENT FROM THE ONE WHERE I PURCHASED THE VEHICLE) AND THEY INFORMED ME THAT WHEN THEY PULLED THE VIN, I…
Read full complaint
I PURCHASED A 2014 TOYOTA PRIUS ON MAY 31, 2014. TODAY 6/18/14 I FOUND OUT THERE WAS A RECALL ON THIS MODEL VEHICLE. I CALLED TOYOTA AND I WAS INFORMED THE RECALL SERVICE HAD NOT BEEN PERFORMED. I CALLED A LOCAL DEALER (DIFFERENT FROM THE ONE WHERE I PURCHASED THE VEHICLE) AND THEY INFORMED ME THAT WHEN THEY PULLED THE VIN, IT SHOWED STOP SALE IN EFFECT. I DO NOT BLAME TOYOTA AS OBVIOUSLY IF ONE DEALER COULD SEE THE STOP SALE SO COULD THE OTHER. I THINK THAT THERE SHOULD BE STRICTER REGULATIONS ON DEALERSHIPS TO MAKE SURE THESE RECALLS ARE COMPLETED BEFORE THE SALE!! JUST LIKE THE GENTLEMAN THAT COMPLAINED EARLIER I ALSO PURCHASED A BRAND NEW DEFECTIVE VEHICLE, HOW CAN THIS HAPPEN SEVERAL MONTHS AFTER THE RECALL. !! NOW I HAVE TO TAKE THE TIME OFF TO TAKE IT IN TO HAVE THE RECALL FIXED. THIS IS A MAJOR INCONVENIENCE, LOSS OF USE OF VEHICLE AND LOSS OF TIME FROM WORK. I ALSO WANT TO KNOW HOW TO GET COMPENSATED FOR THE INCONVENIENCE AND TIME, PLUS THE FACT THEY SOLD AND I HAVE BEEN DRIVING AN UNSAFE VEHICLE. *TR
NHTSA ODI #10599173
Mileage unknown · Apr 28, 2014
Hybrid Propulsion System
2014 TOYOTA PRIUS. CONSUMER WRITES IN REGARDS TO ELECTRICAL SYSTEM SOFTWARE RECALL NOTICE AND REQUESTS FINANCIAL COMPENSATION. *SMD THE CONSUMER STATED TOYOTA AND THE DEALER KNOWINGLY SOLD HIM A DEFECTIVE VEHICLE, IN WHICH THEY WERE FULLY AWARE OF RECALL # 14V053000. *JB
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2015 Prius and 2014-2017 Prius V vehicles not included in recall 18V-684. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: An unexpected hybrid power system shut down may increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will perform a software update for the hybrid system. If the vehicle has experienced an inverter failure with certain hybrid system faults related to this condition, the inverter assembly will be repaired or replaced, prior to software update. All repairs will be performed free of charge. This recall began July 24, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB10 / 20TA10.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
2014 Toyota Prius Problems, Complaints & Recalls | Skip That Year
Illustration