2008 Toyota Tacoma

Toyota has had a long history of excessive frame rust. This truck has excessive frame rust. There was a recall to fix this frame rust and my truck has not been fixed. Toyota will not fix the current recall for the spring replacement because of the frame rust. My life and my children’s lives are in danger due to the possible leaf suspension failure that may puncture the gas tank.

The contact owns a 2008 Toyota Tacoma. The contact stated that during a routine oil change, he was advised that the sub frame had extensive corrosion on the rear and front passenger’s side of the vehicle. There was no warning light illuminated. The contact was informed that the sub frame needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 139,950.

Hope to be able to get this solved. My 2008 Toyota Tacoma had a recall with the previous owner but they didn't take it in. On the rear section of the frame on the inside beside the gas tank and on the driver side there is a lot of rust there the frame has expanded and is starting to go all away through also same place back beside the muffler on the passenger side. Also there are a few spots on the front part of the frame under the fire wall area on both sides. I had a recall on the truck and took it in and had it fixed which Toyota replaced the leaf springs on both sides and hardware. Says there was a recall when the previous owner had the truck. Will they validate that still? I've owned the truck almost a year now. But it's getting worse. Within a year I'm gonna have to park it because it liable to possible break in half. Toyota should of let me known when they had it on the lift replacing the rear leaf springs. Not my fault the previous owner didn't take the truck in to have them look at it.

The contact owns a 2008 Toyota Tacoma. The contact stated while driving 60 MPH, the steering wheel failed to move as intended and the vehicle became difficult to maneuver. An unknown warning light was illuminated. The contact continued driving at a slow speed. The vehicle was taken to an independent mechanic who determined that the pinion steering gear failed and needed to be replaced. The vehicle was repaired. The contact stated that on a separate occasion while driving 40 MPH, there was an abnormal revving sound coming from the engine. The vehicle was taken to an independent mechanic who determined that the engine was leaking oil and the entire braking system needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.

The contact owns a 2008 Toyota Tacoma. The contact stated while receiving an oil change, an independent mechanic discovered severe corrosion with the subframe of the vehicle. The vehicle was taken to the dealer, and the contact was informed that there were no recalls on the VIN and the contact was provided an estimate for the repair. The vehicle was not repaired. The manufacturer was made aware of the failure but offered no assistance. The failure mileage was 130,000.

The contact owns a 2008 Toyota Tacoma. The contact stated that while inspecting the vehicle, it was discovered that underneath the vehicle there was an abnormal amount of rust on the frame. The front passenger side frame was deteriorating. The dealer was called and made aware of the failure however the vehicle was not diagnosed or repaired. The contact mentioned that the vehicle was parked and driven when necessary as they feared for their safety when the vehicle was driven. The manufacturer was notified of the failure and confirmed that the failure was a known issue. The approximate failure mileage was 106,000.

Some of the interior door light switches don't light @ night. I can probably take the door panel off & fix it... (buy bulbs)...? Door hinge on the gas cap breaks way to easily. Could fly off & hit someone\thing... Clunking sound coming from the rear end & I can't find where it's coming from... Gas cap gets loose & throws a p0333 code knock sensor bank 1 or 2 or both. Who put them under the manifold... ? Scary to get the code. That's a hr+ job that's doing it myself.$ Expensive from a shop $ Nothing to serious. 2nd Owner. Runs strong for the miles on it. Thank you, [XXX] , INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

In March of 2008, I purchased a new 2008 Toyota Tacoma (VIN: [XXX] ) from Orleans Toyota in Massachusetts. In July 2010 I re-located to New Hampshire and registered the vehicle in that state in July 2010 where I have resided since. The odometer reading at that time was 21,220 Miles. In September of 2014, I received a safety recall notice from Toyota regarding a potential frame corrosion problem. I scheduled an appointment with the local Toyota dealership in East Swanzy NH on September 12, 2014 to address this issue. The odometer reading at the time was 82,068 miles. There were two remediation options, as set by Toyota: A.Inspect frame, clean, and apply CRC if no perforations were found B.Inspect frame and if perforations found, replace the frame. Both of these options were intended to mitigate any and all risk of future corrosion of the frame that was a result of a known vehicle design flaw. Toyota chose to apply the CRC. I therefore assumed that the frame was intact at that point in time and the issue had been resolved. Between September 2014 and December 2019, I drove the vehicle 62 miles a day on [XXX] in NH commuting between Hillsboro and Keene for all 12 months of the year. This represents a total mileage of 87,939 (36,054 of which can be considered winter driving during the months of November thru March). The Toyota dealership inspected and passed the vehicle in 2023 without mention of any issue regarding the frame. On [XXX] of this year, the Toyota dealership rejected the state inspection due to severe frame corrosion (to the point that the technician felt it was a risk putting the truck on a lift). It should be noted that this vehicle has only been driven 3,000 since it passed inspection in 2023, none of which were during Winter months. In addition, there are no visible signs of rust or corrosion on the exterior of the vehicle. The above points to the fact that the CRC application in 2014 was ineffective in mitigating the safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOI

The contact owns a 2008 Toyota Tacoma. The contact stated that upon taking the vehicle to the dealer for the State inspection, the dealer informed the contact that the subframe was severely corroded, and there was a large hole in the front leaf spring shackles. The dealer determined that the subframe needed to be reinforced at an auto body shop. The dealer provided an estimate for the repair. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that two extended warranty letters related to the failure were sent to the vehicle owners. The manufacturer informed the contact that the Extended Warranties had expired; however, the contact never received the letters. The failure mileage was approximately 107,811.