Air Bags. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seats. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

18 crash reports28 fire reports13 injury reports

Fuel/propulsion System complaints

4 reports

Clear category filter

184,928 miles · Sep 13, 2016

Fuel/propulsion System

FUEL INJECTOR RAIL FAILURE. WOULD LIKE TO KNOW IF THERE WAS A RECALL ON THIS AND IF THE REPAIR IS COVERED UNDER A RECALL. GAS IS LEAKING FROM THE FUEL INJECTOR RAIL, AND VAN WAS CHUGGING. THANK YOU IN ADVANCE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10906069

Mileage unknown · Aug 23, 2016

Fuel/propulsion System

Read full complaint

WHEN I WENT TO VISIT MY WIFE AT THE NURSING HOME WHERE SHE IS, AFTER I GOT IN MY VAN TO GO HOME I ONLY MADE IT A COUPLE MILES THE GAUGES WENT GOOFY THEN THE MOTOR QUIT, I HAD NO CLUE A RELATIVE OWNS A WRECKER SERVICE SO HE CAME AND TOWED ME HOME. THE NEXT DAY I TRIED TO START IT BUT NO LUCK, WHEN I FIRST GOT THE VAN IT DID SOMETHING JUST LIKE THIS SO I FIGURED IT COULD BE THE BRAIN SO I GOT ONE AND PUT IT IN, NOTHING SO WHILE TURNING THE ENGINE OVER I DIDN'T HEAR THE FUEL PUMP SO I BOUGHT A REPLACEMENT. AFTER GOING THROUGH ALL OF THAT IT STILL WOULD TURN BUT NOT START A MECHANIC CAME OUT TO LOOK AT IT AND SEE IF HE COULD FIGURE OUT WHY IT DIDN'T START AFTER LOOKING AT IT HE SAID THAT IT WAS PROBABLY THE FUEL SHUT OFF RELAY, THAT'S WHERE IT IS,I NEED TO FIND WHERE THE CUTOFF RELAY IS LOCATED SO I CAN RESET IT.

NHTSA ODI #10897839

195,354 miles · Feb 16, 2015

Fuel/propulsion System

LEAKING FUEL FROM FUEL RAIL IN FRONT OF MANIFOLD. THERE IS A VALID RECALL, YET CHRYSLER WOULD NOT COVER TOWING VEHICLE EVEN THOUGH THERE IS A DANGEROUS SITUATION WITH FUEL LEAKING ONTO THE ENGINE. I VERY MUCH BELIEVE THAT CHRYSLER SHOULD COVER TOWING. *TR

NHTSA ODI #10683677

111,365 miles · May 14, 2013

Fuel/propulsion System

Read full complaint

WHEN I STARTED THE CAR THE ENGINE WAS COLD FROM SITTING IN THE DRIVEWAY ALL NIGHT. I SMELLED GASOLINE. I OPENED THE HOOD TO FIND GASOLINE SHOOTING OUT OF THE FUEL HOSE RIGHT WHERE IT FITS INTO THE PRESSED CRIMPED METAL CONNECTION. IT WAS SPRAYING GASOLINE ALL OVER THE ENGINE. I TURNED OF THE ENGINE BEFORE IT BECAME HOT. IF THIS LEAK HAD OCCURRED WHILE DRIVING, THE MOTOR WOULD HAVE BEEN HOT, AND CAUGHT FIRE. THE GARAGE REPLACED THE PLENUM GASKET SET, FUEL INJECTION, O RING, AND THE FUEL RAIL. NOTE: THE RECALL #RQ00008 DC MINIVAN FUEL INJECTOR RAIL LEAK WAS DONE. *TR

NHTSA ODI #10512026

Official recalls

04V480000 · Air Bags

Oct 6, 2004

ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.

Consequence & remedy

Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.

Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

02V076000 · Seat Belts:rear/other

Mar 8, 2002

ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

01V119000 · Seat Belts:front:retractor

Apr 11, 2001

VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.

Consequence & remedy

Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

00V268000 · Fuel System, Gasoline:fuel Injection System

Sep 13, 2000

VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.

Consequence & remedy

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA04013 · Driver Air Bag Clockspring Failure

Opened Jun 4, 2004 · Closed May 25, 2005

Status: closed (inferred from source dates) · Air Bags:frontal

THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.

PE04017 · Overheating Of Seat Heaters

Opened Feb 18, 2004 · Closed Jun 21, 2004

Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler

ODI OPENED THIS INVESTIGATION BASED ON 24 COMPLAINTS ALLEGING THAT THE ELECTRICALLY HEATED DRIVER OR PASSENGER SEAT SPARKS/OVERHEATS.DAIMLERCHRYSLER BELIEVES THE FAILURE IS DUE TO ONE OF TWO FACTORS:THE STITCHING OPERATION ON THE SEAT COVER MAY CAUSE THE SEWING NEEDLE TO SEVER SOME STRANDS OF THE WIRE HEATING GRID IN THE SEAT, OR A POOR SOLDER JOINT/WIRE CONNECTOR FAILS DUE TO IMPROPER PROCESSING OR LONG TERM OVERSTRESSING.THE IGNITION SWITCH AND THE SEAT HEATER SWITCH MUST BOTH BE TURNED ON TO POWER THE SEAT HEATER.COMPLAINANTS REPORT THAT WHEN OVERHEATING OCCURS, SWITCHING THE HEATER OFF ALSO STOPS THE OVERHEATING.THE FAILURE CANNOT OCCUR IN AN UNATTENDED VEHICLE WITH THE IGNITION SWITCH OFF.ODI FINDS THAT THE 33 FIRE ALLEGATIONS ARE REPORTING VERY LOCALIZED OVERHEATING(PHOTOS OF DAMAGED SEATS SHOW HOLES THE SIZE OF A PENCIL OR LESS).THERE ARE NO REPORTS OF SUSTAINED COMBUSTION AND NO REPORTS OF OTHER FIRE DAMAGE TO THE VEHICLE.THE INJURY ALLEGATIONS ARE REPORTING MINOR INJURY.NO CONSUMERS REQUIRED MEDICAL TREATMENT (PHYSICIAN CARE).THERE ARE NO ALLEGATIONS OF LOSS OF VEHICLE CONTROL DUE TO FAILURE OF A HEATED SEAT.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

RQ04001 · Driver Air Bag Clockspring Failure

Opened Jan 28, 2004 · Closed Jun 4, 2004

Status: closed (inferred from source dates) · Air Bags:frontal

COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).

EA01007 · Air Bag Clockspring

Opened Feb 21, 2001 · Closed Nov 22, 2002

Status: closed (inferred from source dates) · Electrical System

There is no summary currently available

PE00034 · Overheating Of Front Seat Heaters

Opened Aug 31, 2000 · Closed Jan 5, 2001

Status: closed (inferred from source dates) · Electrical System

ALLEGE THAT THE FRONT SEATS OVER HEAT AND SMOKE OR CATCH FIRE

RQ00008 · Dc Minivan Fuel Injector Rail Leak

Opened Mar 9, 2000 · Closed Mar 18, 2002

Status: closed (inferred from source dates) · Vehicle Speed Control:linkages

There is no summary currently available

EA99013 · Post Collision Fuel System

Opened Jun 11, 1999 · Closed Aug 10, 2001

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

No summary supplied.

PE99010 · POST-COLLISION Fuel System Integrity

Opened Feb 3, 1999 · Closed Jun 11, 1999

Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

There is no summary currently available