WHEN WE (FAMILY OF 4) WERE BACKING OUT OF OUR DRIVE WAY, AT/ABOUT 5MPH, A LOUD METALLIC NOISE WAS HEARD. IT APPEARED TO COME FROM UNDER THE VAN, FRONT/LEFT SIDE. WE PARKED THE VAN AND LOOKED UNDER THE VAN, EVERYTHING LOOKED NORMAL. BUT THE NOISE WAS QUITE LOUD AND WE KNEW SOMETHING WAS NOT CORRECT. WE DROVE THE VAN ABOUT 50 FEET…
Read full complaint
WHEN WE (FAMILY OF 4) WERE BACKING OUT OF OUR DRIVE WAY, AT/ABOUT 5MPH, A LOUD METALLIC NOISE WAS HEARD. IT APPEARED TO COME FROM UNDER THE VAN, FRONT/LEFT SIDE. WE PARKED THE VAN AND LOOKED UNDER THE VAN, EVERYTHING LOOKED NORMAL. BUT THE NOISE WAS QUITE LOUD AND WE KNEW SOMETHING WAS NOT CORRECT. WE DROVE THE VAN ABOUT 50 FEET IN OUR CUL-DE-SAC AND HEARD ANOTHER METALLIC NOISE AND SOMETHING FELL UNDER THE VAN. WHEN WE LOOKED UNDER THE VAN, WE FOUND A PIECE OF SUSPENSION SPRING, ABOUT 9 INCHES LONG. THE PIECE WAS NOT RUSTED OR BRITTLE, IT LOOKED PRETTY STONG, BUT APPEARED TO HAVE BEEN SUDDENLY BROKEN/SNAPPED. LUCKY THAT IT DID NOT HAPPEN WHEN WE WERE ARE ON ANY HIGHWAY OR AT A HIGHER SPEED. LATER WE TOOK VAN TO GET, THE SPRINGS/STRUTS REPLACED. A GOOGLE SEARCH FOUND OUT THAT WE WERE NOT ALONE, THIS SEEM TO HAVE HAPPENED LOTS OF OTHER FAMILIES. A TYPICAL WEBSITE EXAMPLE IS BELOW. I COULD FIND MANY MORE. THIS LOOKS LIKE A SYSTEMIC OR MATERIAL PROBLEM WITH THESE SPRINGS AND HONDA MUST DO SOMETHING SO THAT NONE WOULD GET INJURED OR HURT. HTTP://WWW.CARPROBLEMZOO.COM/HONDA/ODYSSEY/FRONT-SUSPENSION-COIL-SPRING-PROBLEMS.PHP. *TR
NHTSA ODI #10498487
142,199 miles · Jul 24, 2012
Suspension
CAR BEGAN TO RUMBLE AND VIBRATE WHEN I PULLED INTO MY GARAGE. THERE WAS A LOUD POP NOISE WHEN ENGINE WAS SHUT OFF AND AGAIN WHEN I STARTED IT THE NEXT MORNING. THOUGHT IT WAS AN EXHAUST PROBLEM BUT MY RIGHT FRONT ENGINE MOUNT WAS BROKEN AND NEEDED TO BE REPLACED. AFTER SEARCHING ONLINE TO FIND OUT MORE ABOUT ENGINE MOUNTS I F…
Read full complaint
CAR BEGAN TO RUMBLE AND VIBRATE WHEN I PULLED INTO MY GARAGE. THERE WAS A LOUD POP NOISE WHEN ENGINE WAS SHUT OFF AND AGAIN WHEN I STARTED IT THE NEXT MORNING. THOUGHT IT WAS AN EXHAUST PROBLEM BUT MY RIGHT FRONT ENGINE MOUNT WAS BROKEN AND NEEDED TO BE REPLACED. AFTER SEARCHING ONLINE TO FIND OUT MORE ABOUT ENGINE MOUNTS I FOUND THIS IS A VERY COMMON ISSUE WITH THE HONDA ODYSSEY. MORE THAN LIKELY, I WILL BE NEEDING THE OTHER MOUNTS REPLACED IN THE NEAR FUTURE. IF SOMEONE THINKS IT IS AN EXHAUST ISSUE, THEY MAY PUT OFF HAVING IT CHECKED WHICH CAN PUT STRESS ON THE OTHER MOUNTS. SEEMS TO ME WITH THE FREQUENCY OF THIS HAPPENING TO THIS MODEL CAR, IT SHOULD BECOME A RECALL ISSUE. CAN BE A DEFINITE SAFETY HAZARD IF SEVERAL OF THE MOUNTS BREAK AT THE SAME TIME. *TR
NHTSA ODI #10467258
143,000 miles · Mar 22, 2012
Suspension
FRONT SUSPENSION SPRING BROKE. RUBS TIRE ON TURNS. VEHICLE HANDLES POORLY. *TR
NHTSA ODI #10452715
142,000 miles · Mar 20, 2011
Suspension
SMELLED BURNING RUBBER WHEN DRIVING MY 2000 HONDA ODYSSEY. ALSO HEARD RUBBING AND POPPING SOUNDS. FOUND BOTH FRONT COIL SPRINGS HAD BROKEN. ABS LIGHT ALSO STAYS ON AND WON'T GO OFF. BOTH SPRINGS BROKE IN SAME PLACE....MAKING ME THINK THERE WAS A DEFECT IN THESE SPRINGS. *TR
NHTSA ODI #10392249
90,000 miles · Mar 3, 2011
Suspension
CLUNKING IN THE FRONT DRIVER'S AREA. THEN SOUNDED LIKE A LOOSE PART IN THE SAME AREA. TURNS OUT THE DRIVER'S FRONT COIL CRACKED AND BROKE OFF. TOP PORTION, MAYBE ABOUT 1 COIL'S WORTH. *TR
NHTSA ODI #10386383
125,000 miles · Jan 25, 2010
Suspension
TL*THE CONTACT OWNS A 2000 HONDA ODYSSEY. THE VEHICLE WAS PARKED AND SUDDENLY, A LOUD NOISE WAS COMING FROM THE VEHICLE, FOLLOWED BY THE FRONT END OF THE VEHICLE COLLAPSING TO THE GROUND. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THE FAILURE WAS CONTRIBUTED TO THE FRONT PASSENGER COIL SPRING BROKE. …
Read full complaint
TL*THE CONTACT OWNS A 2000 HONDA ODYSSEY. THE VEHICLE WAS PARKED AND SUDDENLY, A LOUD NOISE WAS COMING FROM THE VEHICLE, FOLLOWED BY THE FRONT END OF THE VEHICLE COLLAPSING TO THE GROUND. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THE FAILURE WAS CONTRIBUTED TO THE FRONT PASSENGER COIL SPRING BROKE. CURRENTLY, THE VEHICLE IS BEING REPAIRED FOR THE MALFUNCTION. THE FAILURE MILEAGE WAS 125,000. UPDATED 02/17/10. *LJ THE REPAIR WAS COMPLETED. UPDATED 02/18/10
NHTSA ODI #10302160
102,000 miles · Jan 19, 2010
Suspension
RIGHT FRONT SUSPENSION COIL SPRING SNAPPED IN HALF. SEE NHTSA ACTION NUMBER : PE06007. *TR
NHTSA ODI #10300332
103,000 miles · May 1, 2009
Suspension
2000 HONDA ODYSSEY WITH ~103K MILES. NORMAL WEAR AND TEAR. BROKEN RIGHT FRONT SPRING. COULD HAVE CAUSED SERIOUS INJURY IF SPRING WOULD CUT TIRE AT HIGHWAY SPEEDS. WILL BE REPLACING NEXT WEEK. *TR
NHTSA ODI #10267425
101,000 miles · Feb 26, 2009
Power TrainSuspension
2000 HONDA ODYSSEY COIL SPRING FAILURE ON DRIVERS SIDE AND TRANSMISSION FAILURE. *TR
NHTSA ODI #10260154
135,200 miles · Jan 9, 2009
Suspension
WHILE DRIVING ON A CITY STREET, A LOUD NOISE FROM THE RIGHT SIDE. ABS LIGHT CAME ON, BUT RESET AFTER RESTARTING VAN. STOPPED AND LOOKED UNDER VAN, BUT ALL LOOKED OKAY. WHEN DRIVING CAR WOULD SUDDENLY PULL HARD TO RIGHT. NOISE CONTINUED AND NEXT DAY REPAIR SHOP INFORMED THAT RIGHT COIL SPRING WAS BROKEN AND WE WERE LUCKY IT DIDN'…
Read full complaint
WHILE DRIVING ON A CITY STREET, A LOUD NOISE FROM THE RIGHT SIDE. ABS LIGHT CAME ON, BUT RESET AFTER RESTARTING VAN. STOPPED AND LOOKED UNDER VAN, BUT ALL LOOKED OKAY. WHEN DRIVING CAR WOULD SUDDENLY PULL HARD TO RIGHT. NOISE CONTINUED AND NEXT DAY REPAIR SHOP INFORMED THAT RIGHT COIL SPRING WAS BROKEN AND WE WERE LUCKY IT DIDN'T PUNCTURE TIRE. THEY CUT A PORTION OF THE SPRING AWAY TO KEEP SPRING FROM CAUSING BLOWOUT. NOT REPAIRED AS COST PROHIBITIVE. *TR
Honda (American Honda Motor Co.) is recalling certain 1998 Acura 2.2CL, 1998-1999 Acura 2.3CL, 1998-1999 Acura 3.0CL, 2001 Acura 3.2CL and Acura MDX, 1998-2000 Honda Accord Coupe, Accord Sedan, Civic Sedan, Odyssey and Acura 3.5RL, 1999-2000 Acura 3.2TL, 1996-2000 Civic Coupe, 1997-2000 CR-V, 1997-1998 EV Plus, and 1998-1999 Isuzu Oasis vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the driver frontal air bag inflator, and replace it if necessary, with an inflator of a different design, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138 or Isuzu customer service at 1-800-255-6727.
Honda (American Honda Motor Co.) is recalling certain 2001-2002 Acura 3.2CL, 2000-2003 Acura 3.5RL, 2000-2001 Acura 3.2TL, Honda CR-V and Honda Odyssey, 2001-2002 Acura MDX and 2000 Accord Coupe, Accord Sedan, Civic Coupe, and Civic Sedan vehicles. These vehicles may have received a replacement driver frontal air bag module as part of a vehicle repair. Due to a manufacturing issue, the replacement NADI inflator may absorb moisture, causing the inflator to rupture or the air bag cushion to underinflate.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag cushion may not properly protect the occupant. These scenarios increase the risk of serious injury or death.
Remedy: Honda will notify owners, and dealers will inspect the air bags in the vehicles, replacing the driver frontal air bag inflator with an inflator of a different design, as necessary, free of charge. The recall began October 1, 2020. Owners may contact American Honda's Customer Support & Campaign Center at 1-888-234-2138.
VEHICLE DESCRIPTION: MINIVAN. THE SLIDING DOORS MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: AN IMPROPERLY LATCHED DOOR COULD OPEN UNEXPECTEDLY WHILE THE VEHICLE IS IN MOTION. UNDER CERTAIN CIRCUMSTANCES, A DOOR COULD OPEN COMPLETELY. AN UNRESTRAINED REAR SEAT PASSENGER COULD FALL OUT OF AN OPEN DOOR OF A MOVING VEHICLE AND BE SERIOUSLY INJURED OR KILLED.
Remedy: DEALERS WILL REPLACE THE DOOR LATCH ASSEMBLY ON ALL ODYSSEY MINVANS BUILT FROM DECEMBER 3, 1999 THROUGH DECEMBER 16, 1999. ALSO INCLUDED IN THIS RECALL ARE APPROXIMATELY 1,612 ODYSSEY MINIVANS THAT HAD THE LATCHES REPLACED UNDER RECALL 99V-158 OR UNDER WARRANTY, THAT MAY NEED TO HAVE THE LATCHES REPLACED AGAIN. OWNERS OF THESE VEHICLES WILL BE NOTIFIED BY HONDA TO BRING THE VEHICLE TO THEIR HONDA DEALER FOR INSPECTION OF THE PREVIOUSLY REPLACED LATCH ASSEMBLY. LATCHES WITH THE SUSPECT DATE CODE WILL BE REPLACED.
VEHICLE DESCRIPTION: MINI VANS. A WIRE HARNESS, LOCATED WITHIN THE ENGINE COMPARTMENT, COULD BE DAMAGED BY CONTACT WITH A METAL PIPE, POSSIBLY RESULTING IN A BLOWN FUSE.
Consequence & remedy
Consequence: IF A FUSE BLOWS, ENGINE POWER, OR OPERATION OF ANY OR ALL ELECTRICAL COMPONENTS, CAN BE LOST, INCLUDING LIGHTS, WINDSHIELD WIPERS, HORN, AND THE ANTI-LOCK FUNCTION OF THE BRAKES. A SUDDEN LOSS OF POWER OR LIGHTING, OR A FAILURE OF THE WINDSHIELD WIPERS OR ANTI-LOCK BRAKE FEATURE IN BAD WEATHER, COULD RESULT.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVERING OVER THE WIRE HARNESS AND METAL PIPE TO PREVENT THIS PROBLEM. IF ANY WIRES ARE DAMAGED, THE DEALER WILL MAKE THE NECESSARY REPAIRS, AND THEN INSTALL THE PROTECTIVE COVERING.
VEHICLE DESCRIPTION: MINIVANS. THE FRONT BODY/FRAME IS MISSING SPOT WELDS.
Consequence & remedy
Consequence: THE MISSING WELDS MIGHT AFFECT THE OCCUPANT PROTECTION PERFORMANCE IN A COLLISION.
Remedy: DEALERS INSPECTED ALL THE VEHICLES AND THEY WERE FOUND TO BE PROPERLY WELDED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE06007 · Front Coil Spring Fracture
Opened Jan 24, 2006 · Closed May 24, 2006
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
THE POPULATION OF 116,000 VEHICLES IS AN ESTIMATE BASED ON AMERICAN HONDA MOTOR COMPANY (AHM) DATA IDENTIFYING ORIGINAL STATE OF SALE OR DELIVERY.THE SUBJECT VEHICLES (SV) UTILIZE LIGHT WEIGHT COIL SPRINGS MANUFACTURED FROM HIGH STRENGTH STEEL (HSS).IF THE COATING MATERIAL OF A HSS SPRING IS BREACHED, CORROSIVE ELEMENTS (SALT) MAY ATTACK THE SPRING.SPRING CORROSION RESULTS IN A STRESS RISER AND MAY CAUSE A FRACTURE.DEPENDING ON THE LOCATION WHERE THE SPRING BREAKS, THE JAGGED EDGE MAY PIERCE THE TIRE; A RAPID DEFLATION OF THE TIRE MAY OCCUR AND CAN RESULT IN A LOSS OF CONTROL OR CRASH.SV SPRING FAILURE MECHANICS AND TIRE CONTACT LIKELIHOOD ARE DISCUSSED IN AN AHM PRESENTATION TO ODI DATED APRIL 20TH, 2006 (AVAILABLE ON ODI?S WEB SITE; WWW-ODI.NHTSA.DOT.GOV).AHM?S PRESENTATION IDENTIFIED TWO MECHANISMS WHICH CAUSE THE SPRING COATING TO BECOME BREACHED; 1) CONTACT WITH THE LOWER SPRING SEAT, AND 2) ENTRAPMENT OF ABRASIVE MATERIALS BETWEEN THE SILENCER TUBE AND SPRING.THE PRESENTATION COMPARED SV SPRING FRACTURE RATES TO THE HONDA MDX MODEL, A SISTER VEHICLE RECALLED FOR FRONT SPRING FRACTURE UNDER NHTSA RECALL 05V385, AND TO OTHER VEHICLES INVESTIGATED AND OR RECALLED FOR FRONT SPRING FRACTURE.THE SPRING FRACTURE RATE FOR THE SV, WHICH IS ABOUT HALF THE RATE OF THE MDX MODEL EVEN THOUGH THE SV'S HAVE ONE YEAR LONGER IN SERVICE, IS COMPARABLE TO RATES OBSERVED IN PRIOR SPRING FRACTURE INVESTIGATIONS THAT WERE CLOSED WITH NO RECALL AND LOW IN COMPARISON TO INVESTIGATIONS THAT HAVE RESULTED IN A SAFETY RECALL.OF THE 7 REPORTS ODI IDENTIFIED ALLEGING TIRE DAMAGE DUE TO SPRING FRACTURE, 6 INVOLVED SPRING-TIRE CONTACT WHICH RESULTED IN SLOW OR NO LOSS OF AIR PRESSURE; ODI WAS UNABLE TO VERIFY THE ONE REPORT ALLEGING A PUNCTURE OCCURRED.ODI NOTES THAT THE SV FRONT SPRING DIFFERS FROM THE MDX SPRING IN THAT IT HAS A SINGLE SILENCER TUBE (UPPER ONLY, AS OPPOSED TO UPPER AND LOWER ON THE MDX) WHICH IS, ACCORDING TO AHM, LOCATED IN AN AREA LESS LIKELY TO RESULT IN A TIRE PUNCTURE SHOULD A FRACTURE OCCUR.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES IS NOT WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
RQ00014 · Upexpected Opening Of Sliding Door
Opened Jul 28, 2000 · Closed Apr 25, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
2000 Honda Odyssey Problems, Complaints & Recalls | Skip That Year
Illustration