IllustrationPASSENGER SIDE BEHIND THE DRIVER'S SEAT'S TIRE BLEW OUT. STARTED TO DRIVE AND CAR WAS MOVING SLOWER AND EVENTUALLY HAD TO PULL OVER BECAUSE CAR FELT UNSTABLE. WAS NOT GIVEN AN ALARM THAT THE TIRE WAS BLOWN AND FLAT. WAS DRIVING LESS THAN 30MPH, IN A STRAIGHT, FLAT STREET.
2019 Toyota Prius Prime
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius Prime years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 6 of 8 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Wheels. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Wheels complaints
4 reports10/19-LEFT REAR TIRE KEPT LOOSING PRESSURE, I TOOK IT TO THE MECHANIC, THEY COULDN'T FIND ANYTHING, I AGAIN TOOK IT AFTER 2 WEEKS, THEY CHANGED THE TIRE. MILES 7014. ON 9/26/20-MILES 16430, THE SAME TIRE LEFT PASSENGER BLEW OUT ON THE FREEWAY. NO INDICATOR OF TIRE PRESSURE BEING LOW CAME ON. THE TIRE WAS COMPLETELY BLOWN OUT. …
Read full complaint
10/19-LEFT REAR TIRE KEPT LOOSING PRESSURE, I TOOK IT TO THE MECHANIC, THEY COULDN'T FIND ANYTHING, I AGAIN TOOK IT AFTER 2 WEEKS, THEY CHANGED THE TIRE. MILES 7014. ON 9/26/20-MILES 16430, THE SAME TIRE LEFT PASSENGER BLEW OUT ON THE FREEWAY. NO INDICATOR OF TIRE PRESSURE BEING LOW CAME ON. THE TIRE WAS COMPLETELY BLOWN OUT. I LOST CONTROL OF THE CAR, THANKFULLY IT STOPPED ON LEFT SIDE. IT WAS VERY SCARY. NO WAS HURT, BUT I COULD HAVE DIED. I WAS DRIVING ABOUT 70MPH.
2 TOYOTA COMPLAINTS: 1) MY 2019 PRIUS PRIME 11,597 MILES: ON HWY 85 SOUTH 11/27 10:30PM GOT FLAT TIRE & DROVE TO SIDE LANE ON HWY. CALLED TOYOTA TOW SERVICE @ 10:37PM WHICH IS IN GEORGIA NOT CALIF. TOW NOT SHOW UNTIL 1:16AM 11/27 AND TOWED CAR TO DEALER. IT TOOK 20 MIN. FOR CALL CENTER IN GEORGIA TO INITIATE TOW 2) THE PRIUS …
Read full complaint
2 TOYOTA COMPLAINTS: 1) MY 2019 PRIUS PRIME 11,597 MILES: ON HWY 85 SOUTH 11/27 10:30PM GOT FLAT TIRE & DROVE TO SIDE LANE ON HWY. CALLED TOYOTA TOW SERVICE @ 10:37PM WHICH IS IN GEORGIA NOT CALIF. TOW NOT SHOW UNTIL 1:16AM 11/27 AND TOWED CAR TO DEALER. IT TOOK 20 MIN. FOR CALL CENTER IN GEORGIA TO INITIATE TOW 2) THE PRIUS PRIME DOES NOT COME WITH A SPARE TIRE BUT HAS A TIRE PUNCTURE REPAIR KIT. MY TIRE BEYOND PUNCTURE REPAIR. A CAR WITH NO SPARE TIRE OF ANY KIND IS EXTREMELY DANGEROUS SITUATION FOR ANYONE. 2019 PRIUS PRIMES DON'T COME WITH SPARE TIRE. THIS HAZARD FEATURE NEEDS TO CHANGE. I HAVE EXPENDED WARRANTY AND SERVICE CONTRACT AND TIRE WAS NOT COVERED SO BESIDES THE UNSAFE CONDITION MY HUSBAND ENDURED WE ALSO GOT A BILL FOR $168.19 TO REPLACE AND INSTALL THE DAMAGED TIRE. I WILL WRITE TO TOYOTA ROADSIDE ASSIST. REGARDING GEORGIA CENTER DISPATCHING TOWS IN CALIF.? & TOYOTA TO COMPLAIN ABOUT NO SPARE TIRE AND A DESIGN INSTEAD OF LIFT BACK MAYBE SIDE OPENING LIKE JEEP SO SPARE TIRE CAN GO ON BACK LIKE JEEP SPARE. I HAVE READ ON YELP ABOUT OTHER TOYOTA OWNERS COMPLAINING ABOUT NO SPARE TIRE.
CAR HAD 27540 MILES ON FACTORY ORIGINAL TOYO NANOENERGY TIRES WHEN THE REAR PASSENGER TIRE BLEW OUT. I WAS 22 MILES INTO MY DRIVE HOME . NO TPS WARNING AND I HAD VISUALLY LOOKED AT MY TIRES BEFORE HEADING HOME. THE ENTIRE TREAD SEPARATED FROM THE SIDEWALLS. THE SIDEWALLS STAYED WITH THE RIM AND I WAS ABLE TO SAFELY STOP THE CAR …
Read full complaint
CAR HAD 27540 MILES ON FACTORY ORIGINAL TOYO NANOENERGY TIRES WHEN THE REAR PASSENGER TIRE BLEW OUT. I WAS 22 MILES INTO MY DRIVE HOME . NO TPS WARNING AND I HAD VISUALLY LOOKED AT MY TIRES BEFORE HEADING HOME. THE ENTIRE TREAD SEPARATED FROM THE SIDEWALLS. THE SIDEWALLS STAYED WITH THE RIM AND I WAS ABLE TO SAFELY STOP THE CAR ON THE GRASS MEDIAN. THIS TYPE OF SIDEWALL BLOWOUT HAS NEVER HAPPENED IN ALL MY YEARS OF DRIVING. I WAS ON US-321 NORTH BOUND JUST AFTER THE HARDIN RD EXIT GOING 70 MPH AT TIME OF BLOWOUT. NOT IN A TURN BUT NEARLY STRAIGHT LINE DRIVING. WEATHER WAS MOSTLY SUNNY AND 65 DEGREES.
Official recalls
119V544000 · Electronic Stability Control (esc); Service Brakes
Jul 24, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Lexus LS500, LC500, ES300h, UX250h, LS500h, Toyota Prius, RAV4 HV, 2019-2020 Toyota Prius Prime, and 2020 Corolla HV vehicles. The brake booster pump may fail causing a deactivation of the Vehicle Stability Control system and a loss of braking assist. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Deactivation of the vehicle stability control system or a loss of braking assist increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect and, if necessary, replace the brake booster pump, free of charge. The recall began September 20, 2019. Toyota owners may contact Toyota customer service at 1-888-270-9371 and Lexus owners may contact Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are K1L/K0L. Lexus' numbers for this recall are K2F/KLF.
Additional source detail variants (2)
Service Brakes
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Lexus LS500, LC500, ES300h, UX250h, LS500h, Toyota Prius, RAV4 HV, 2019-2020 Toyota Prius Prime, and 2020 Corolla HV vehicles. The brake booster pump may fail causing a deactivation of the Vehicle Stability Control system and a loss of braking assist. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Consequence: Deactivation of the vehicle stability control system or a loss of braking assist increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect and, if necessary, replace the brake booster pump, free of charge. The recall began September 20, 2019. Toyota owners may contact Toyota customer service at 1-888-270-9371 and Lexus owners may contact Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are K1L/K0L. Lexus' numbers for this recall are K2F/KLF.
Electronic Stability Control (esc)
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Lexus LS500, LC500, ES300h, UX250h, LS500h, Toyota Prius, RAV4 HV, 2019-2020 Toyota Prius Prime, and 2020 Corolla HV vehicles. The brake booster pump may fail causing a deactivation of the Vehicle Stability Control system and a loss of braking assist. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems."
Consequence: Deactivation of the vehicle stability control system or a loss of braking assist increases the risk of a crash.
Remedy: Toyota will notify owners, and dealers will inspect and, if necessary, replace the brake booster pump, free of charge. The recall began September 20, 2019. Toyota owners may contact Toyota customer service at 1-888-270-9371 and Lexus owners may contact Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are K1L/K0L. Lexus' numbers for this recall are K2F/KLF.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.