2025 Toyota Tacoma

The interior door handle snapped and failed completely under normal operation, causing an immediate loss of driver egress. The handle went limp, leaving the door impossible to open from inside the cabin and creating an entrapment hazard in the event of an emergency. Exiting the vehicle requires the window to be rolled down to access the exterior handle. The failure occurred suddenly with no prior warning or indication of potential failure. The vehicle was taken to an authorized Toyota dealership, which confirmed internal component failure and ordered a replacement assembly under warranty. The dealership noted the replacement part is currently on national backorder due to high replacement volume.

While attempting to exit my vehicle the inner door handle on the driver side felt loose. I attempted to open the door and the door would not open. I carefully attempted to manually move the lock on the door from unlocked to locked back to unlocked and again tried to carefully exit the vehicle but the inner door handle was inoperable. I am now forced to roll my window down and open my vehicle door from the outside to use the door

Fourth generation Toyota Tacoma interior door handles -- 2024, 2025, 2026 -- suffer from an engineering or manufacturing defect. These handles are breaking during normal use, by the thousands. This is a serious safety risk, as drivers with limited mobility, or even fully-abled drivers can be entrapped within the vehicle during an emergency. A regular pull, let alone a hard pull, routinely snaps the mechanism. Toyota dealer has 1000+ backlog of repairs. This is a serious safety risk and a recall is critical. Drivers will die if this is not addressed; it is merely a matter of time.

Few months back, the driver side door handle "broke" on the inside. There is some plastic piece/mechanism that attaches the door handle to the cable on the inside of the door that allows the user to open the door, with resistance from the cable. That piece broke, so it made the handle loose and flimsy, unable to open the door from the inside. Toyota said that was a known issue and that the parts were on backorder, so they just swapped the handle from my back passenger driver side door with my front driver side door. Well last week, the swapped handle also broke. So, I have to roll my window down and open the door from outside to get out as neither of my left side door handles work. Toyota still doesn't have an eta of when parts will ship to replace the pieces, and they aren't offering me a resolution in the meantime.

Equipment Failure. The interior driver-side door handle mechanism failed and snapped completely off during normal operation while trying to exit stationary vehicle. The plastic hinge pin/bell-crank component fractured internally under standard hand pressure. This component failure completely prevents the driver from exiting the cabin from the inside, creating an immediate emergency entrapment and life-safety hazard. The manufacturer (Toyota) currently has the replacement door handle assembly on a national backorder with no available ETA, forcing consumers to operate a vehicle with a compromised emergency exit route. The vehicle currently approximately 3429 miles

The inside driver-side door handle broke, leaving me unable to open the door from inside the truck. I had to crawl across the truck and exit through another door. This is a serious and immediate safety hazard. The driver must be able to exit the vehicle quickly in an emergency. If there were a fire, accident, or other emergency, a broken interior door handle could trap the driver inside the vehicle and potentially result in serious injury or death.

Drive door handle broke became loose floppy, took to dealer, they took apart.... been waiting for parts 2 weeks.... today handle , went full failure and wont engage lock to open, can't open door from inside, have to open window to use outside handle to open door while inside, safety issue... called dealer, clam waiting on part..... Toyota knows of the issue, seen in the Toyota forum that the issue is know and both door drivers and passenger side can have this issue....really don't like that feeling of being trapped. Toyota should have a replacement upgrade to fit safety margins....i've only own my truck 1 year.....this issue start a few weeks ago...hoping the part gets to the dealer fast and the right fixes meet safety standards...