STRUT TOWERS ARE CORRODED TO THE POINT YOU CAN SEE THROUGH THE TOP OFF THE STRUT TOWER HALFWAY AROUND THE TOP. THERE IS NUMEROUS COMPLAINTS OF THIS AND IF I HAD NOT BEEN INFORMED OF THIS IT WOULD HAVE LEAD TO A FAILURE OF THE STRUT SUPPORT. I AM CONCERNED THAT THIS HAS NOT BEEN ADDRESSED PREVIOUSLY. I CALLED THE MANUFACTURE AND …
Read full complaint
STRUT TOWERS ARE CORRODED TO THE POINT YOU CAN SEE THROUGH THE TOP OFF THE STRUT TOWER HALFWAY AROUND THE TOP. THERE IS NUMEROUS COMPLAINTS OF THIS AND IF I HAD NOT BEEN INFORMED OF THIS IT WOULD HAVE LEAD TO A FAILURE OF THE STRUT SUPPORT. I AM CONCERNED THAT THIS HAS NOT BEEN ADDRESSED PREVIOUSLY. I CALLED THE MANUFACTURE AND THEY ARE AWARE OF THE PROBLEM ALTHOUGH THEY ARE NOT WILLING TO REPAIR IT AT THEIR COSTS. PLEASE JUST DO A SEARCH OF THE INTERNET. YOU WILL FIND THIS IS A ISSUE THAT REQUIRES IMMEDIATE ATTENTION IN ORDER TO SAVE LIVES OR INJURIES. *TR
NHTSA ODI #10352610
143,000 miles · Sep 13, 2005
Structure
CORROSION AND FAILURE OF STRUT TOWERS. THIS IS A COMMON PROBLEM ADDRESSED BY CHRYSLER TSB#23-044-02 STATING IT IS "COSMETIC". PLEASE VISIT THE ALLPAR FORUMS (HTTP://ALLPAR.COM/FORUMS/)ON MINIVANS AND YOU WILL SEE THE DISCUSSION. TOWER FAILED AND ALLOWED PARTIAL SUSPENSION COLLAPSE. *JB
NHTSA ODI #10136384
80,000 miles · Sep 5, 2005
Structure
THE DRIVER SIDE STRUT TOWER HAS RUSTED THROUGH ON TOP AT LEAST HALFWAY AROUND. THE ESTIMATE FOR REPAIR FROM THE DEALERSHIP IS $1200.00. *JB
NHTSA ODI #10135360
Mileage unknown · Oct 19, 2004
Structure
WHILE PLACING THE REAR HATCH UP A PIECE SHEARED OFF. THIS CAUSED THE HATCH TO CLOSE WITHOUT WARNING. THE CONSUMER WAS ABLE TO DRIVE IT TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE CONSUMER THAT THE VEHICLE WAS OPERATING AS DESIGNED. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
NHTSA ODI #10097187
95,000 miles · Jan 15, 2004
Air BagsPower TrainStructure
1. THE REAR HATCH LEAKED UPON DELIVERY. THREE ATTEMPTS WERE MADE TO PUT SOME KING OF SEALANT ON THE EXTERIOR TO PREVENT LEAKAGE. SOME WATER DAMAGE TO INTERIOR WAS NEVER FIXED. 2. AIR BAG LIGHT ON DUE TO CLOCK SPRING FAILURE. WAITED FOR ALMOST TWO YEARS FOR CHRYSLER TO ISSUE RECALL WHILE PROBLEM WAS BEING INVESTIGATED BY NHT…
Read full complaint
1. THE REAR HATCH LEAKED UPON DELIVERY. THREE ATTEMPTS WERE MADE TO PUT SOME KING OF SEALANT ON THE EXTERIOR TO PREVENT LEAKAGE. SOME WATER DAMAGE TO INTERIOR WAS NEVER FIXED. 2. AIR BAG LIGHT ON DUE TO CLOCK SPRING FAILURE. WAITED FOR ALMOST TWO YEARS FOR CHRYSLER TO ISSUE RECALL WHILE PROBLEM WAS BEING INVESTIGATED BY NHTSA. 3. TRANSMISSION FAILURE AT 115,800KM. ESTIMATED $1,800 TO REPAIR AT TRANSMISSION SHOP.
NHTSA ODI #10071389
Mileage unknown · Jun 3, 2003
Structure
TOWER STRAP HOUSING PROBLEMS. THEY ARE RUSTING OUT WHERE THE STRAPS ARE ATTACHED TO THE BODY. MANUFACTURER WAS CONTACTED, AND STATED THAT VEHICLE ONLY HAS WARRANTY FOR FIVE YEARS OR 100.000 MILES, AND THAT THERE WAS NOTHING THEY COULD DO BECAUSE THE CONSUMER'S VEHICLE HAS MORE THEN 100.000 MILES.*AK
NHTSA ODI #10022185
77,904 miles · Nov 14, 2002
Power TrainStructure
THE CONSUMER'S SON WAS DRIVING WHEN THE TRANSMISSION FAILED. MASSIVE AMOUNTS OF METAL WAS FOUND INSIDE OF THE DIFFERENTIAL. THE TRANSMISSION WOULD ONLY GO IN REVERSE. THE SLIDING DOOR MOTOR FAILED AND THE DRIVERSIDE POWER LOCKS ON THE DRIVER SIDE SLIDE DOOR HAD BECOME INOPERATIVE. THE CONSUMER REQUESTED REIMBURSEMENT. SCC …
Read full complaint
THE CONSUMER'S SON WAS DRIVING WHEN THE TRANSMISSION FAILED. MASSIVE AMOUNTS OF METAL WAS FOUND INSIDE OF THE DIFFERENTIAL. THE TRANSMISSION WOULD ONLY GO IN REVERSE. THE SLIDING DOOR MOTOR FAILED AND THE DRIVERSIDE POWER LOCKS ON THE DRIVER SIDE SLIDE DOOR HAD BECOME INOPERATIVE. THE CONSUMER REQUESTED REIMBURSEMENT. SCC
NHTSA ODI #567850
Mileage unknown · Jul 10, 1997
Structure
THE SLIDING DOOR ON PASSEGER'S SIDE CANNOT BE OPENED WITH KEY. ALSO OWNER NOTES PROBLEMS WITH OPENING INSIDE LOCK. OWNER IS VERY CONCERNED ABOUT THE PROBLEM. *AK
NHTSA ODI #814049
Mileage unknown · Dec 4, 1996
Structure
BOTH FRONT DOORS SEPARATED FROM THE BODY, CAUSING A MISALIGNMENT WHERE THEY SHOULD MEET THE TOP OF THE BODY. *AK
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
THE STEEL ROAD WHEELS WERE DAMAGED BY THE EQUIPMENT USED TO MATCH MOUNT THE WHEEL TO THE TIRE.
Consequence & remedy
Consequence: A SCORE MARK WAS MADE ON THE WHEEL, AFFECTING THE DURABILITY OF THE WHEEL.
Remedy: DEALERS WILL REPLACE ALL ROAD WHEELS (AND FULL SIZE SPARE TIRES) WITH NEW WHEELS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
PE02004 · Rear Seat Belt Malfunction
Opened Jan 16, 2002 · Closed Mar 11, 2002
Status: closed (inferred from source dates) · Seat Belts:rear/other
THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR BIND.IN THIS CONDITION THE SEAT BELT IS RENDERED INOPERABLE, AS THE WEBBING CANNOT RETRACT OR BE WITHDRAWN FROM THE RETRACTORS FOR USE.RECALL SCOPE:THE AFFECTED VEHICLES ARE 1997 THROUGH 1999 DODGE CARAVAN, PLYMOUTH VOYAGER, AND CHRYSLER TOWN & CONTRY BUILT ON A SHORT WHEEL BASE CHASSIS.THE INCLUSIVE DATES OF PRODUCTION ARE JUNE 1996 THROUGH OCTOBER 31, 1999.RECALL REMEDY: DAIMLERCHRYSLER DEALERS WILL REPLACE THE MASTIC SOUND BARRIER PATCHES WITH FOAM BLOCKERS, AS WELL AS, INSPECT AND REPLACE ALL THIRD ROW REAR SEAT BELT ASSEMBLIES CONTAMINATED BY THE MASTIC PATCH.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
1997 Plymouth Voyager Problems, Complaints & Recalls | Skip That Year
Illustration